Contents
2000 Series
Door-type High Temperature Dishwasher
Manual P/N 114614 rev. J
Model 2000 Series
In Canada
National Service Department
Model Number Serial Number VoltageHertz Phase Service Agent Tel
Parts Distributor Tel
In the U.S.A
In Canada
REGISTER YOUR PRODUCT ONLINE
Serial #
FAILURE TO REGISTER YOUR PRODUCT MAY VOID YOUR WARRANTY
PRODUCT REGISTRATION CARD
Model
Revision History
Revision History
Limited Warranty
LIMITED WARRANTY
Table of Contents
Table of Contents
2000 Series Door-type Dishwasher
Optional Equipment consult factory
Model Description
Model Description
2000 Series
1. Inspect the outside of the dishwasher carton for signs of damage
Installation Receiving
Converting Straight-through Operation to Corner Operation
Installation
wall
Converting Straight-through Operation to Corner Operation
Installation
Electrical Connections
Three Phase Operation
Refer to the next page for 3-phase to
1-phase field conversion instructions
Rewire Booster Heater Element for 1PH
Field Conversion from 3-phase to 1-phase Operation
Install Main Terminal Block Jumper Wire
Rewire Wash Tank Heater Element for 1PH
Hot Water Connection
Drain Connection
Installation
Installation
Vent Fan Control
Chemical Dispenser Provisions
4. DO NOT REMOVE THE JUMPER BETWEEN THE COMMON TERMINALS
Installation Check List
Initial Start-up
is set between 20-25 PSI
Operation
Normal Operation Mode
20-25 PSI
Wash Temperature
Final Rinse Temperature
Normal Operation Mode continued
SANITIZED THE WARES AND THE GREEN CYCLE LIGHT GOES OUT
Rinse Sentry Operation Mode
Automatic Drain Cycle
DO NOT REMOVE WARES UNTIL THE FINAL RINSE CYCLE HAS
Cleaning
Cleaning and Maintenance
After Each Meal Period or every 8 Hours of Operation
Wash Spray arm
Paper Clip
Plug
Rinse Arm Spindle
De-liming
Danger
Cleaning and Maintenance
Cleaning and Maintenance
Maintenance
Daily Maintenance
Weekly Maintenance
Cause
Solution
Troubleshooting
Condition
Page
Service Replacement Parts
Service Replacement Parts
Illustrations
Wash Pump/Motor Assembly
Part
Description
Wash Pump/Motor Assembly
Booster Assembly
JUMPER, STRIP spares used for conversion
Booster Assembly
Part
Description
Control Panel Assembly
Control Panel Assembly
Part
Description
2815
3324
Wash and Rinse Spray Arm Assemblies
Part
Description
Wash and Rinse Spray Arm Assemblies
Hood and Door Assembly
Hood and Door Assembly
Part
Description
Track Assemby
Track Assembly
Part
Description
Wash Tank Heat, Drain, Screens, Hoses
JUMPER, STRIP spare for conversrion
Wash Tank Heat, Drain, Screens, Hoses
Part
Description
Dish Racks, Line Strainer, PRV
Part
Description
Part
Description
Dish Racks, Line Strainer, PRV
Electrical Schematic, Timer Chart
Timer Chart, Electrical Schematic
Timer Chart
Electrical Schematic
RINSE
Timer Chart
TIME CYCLE - DH/MD2000
WASH
AT! TENTION - VERY IMPORTANT
1 & 3 PHASE
Electrical
702119