Generac Power Systems 55, 65 manual Section Exploded Views / Part Numbers, 0C2375

Section 9

Exploded Views / Part Numbers

ITEM	PART NO. QTY.		DESCRIPTION		ITEM	PART NO. QTY.		DESCRIPTION
1	0C2375	2	SCREW HHC M8-1.25 X 90 G8.8	32		055440	2	SCREW HHC M5-0.8 X 25 G8.8
2	022145	2	WASHER FLAT 5/16-M8 ZINC	33		0D9377	1	PANEL, TOP CONTROL
3	029459	2	TENSION SPRING	34		054502	1	CIRCUIT BREAKER 3 X 1
4	075215	2	WASHER, SPRING CENTER	35		031879	4	WASHER FLAT #4 ZINC
5	052858	6	NUT LOCK FL M8-1.25	36		043182	4	WASHER LOCK M3
6	047411	7	SCREW HHC M6-1.0 X 16 G8.8	37		051714	4	NUT HEX M3-0.5 G8 YEL CHR
7	022097	13	WASHER LOCK M6-1/4	38		092234	1	ASSY POTTED RV CNTL
8	022473	10	WASHER FLAT 1/4-M6 ZINC	39		049226	5	WASHER LOCK M5
9	080925	8	WASHER NYLON .404	40		051716	3	NUT HEX M5-0.8 G8 YEL CHR
10	0D9921	4	STANDOFF, 1/2" HEX	41		023484R	2	BUSHING SNAP
11	066849	2	SCREW HHTT M5-0.8 X 16	42		0D3700	1	NUT FLANGE M6-1.0 NYLOK
12	066386	1	ASSY, BRUSH HOLDER	43		0D9378	1	PANEL, BOTTOM CONTROL
13	0C9674	1	BEARING CARRIER, UP	44		052619	1	SCREW HHC M5-0.8 X 20 G8.8
14	0E0363H	1	STATOR ASSEMBLY (5.5 KW ONLY)	45		075476	2	SCREW PPHM M4-0.7 X 16
	0E0364H	1	STATOR ASSEMBLY (6.5 KW ONLY)	46		065795	1	RECTIFIER-BATTERY CHARGE
	0E0362H	1	STATOR ASSEMBLY (7.5 KW ONLY)	47		0C2174	1	RELAY 12V 25A SPST
15	073159	1	BEARING BALL	48		092120	4	NUT LOCK TRIC M6 X 1.0 Y/ZNC
16	077005H	1	ROTOR ASSEMBLY (5.5 KW ONLY)	49		049721	2	SCREW HHC M6-1.0 X 35 G8.8 BLK
	077004H	1	ROTOR ASSEMBLY (6.5 KW ONLY)	50		0A1658	2	WASHER LOCK SPECIAL 1/4"
	073163H	1	ROTOR ASSEMBLY (7.5 KW ONLY)	51		0742600146	1	WIRE ASM GRD STD CONN.
17	031971	1	BEARING	52		049813	4	NUT HEX M6 X 1.0 G8 YEL CHR
18	077006	4	STUD,RV STATOR D/C	53		023484D	1	BUSHING SNAP
19	0C9675	1	BEARING CARRIER, LOW	54		0742600151	1	GROUND WIRE C/PNL TO STUD V-T
20	0A5351	1	NYLON SLIDE					RV
21	073146	2	SLIDE, NYLON	55		084867	1	RUBBER U-CHANNEL
22	0C1878	2	SUPPORT, SLIDE	56		043181	2	SCREW PHM M3-0.5 X 10MM
23	075242	4	SPRING, GEN. MOUNT	57		075210A	1	BLOCK 1 POSITION
24	075237	4	WASHER, SPRING CENTER	58		022264	2	WASHER LOCK #8-M4
25	090145	1	CIRCUIT BREAKER 30 X 1 (5.5 & 6.5	59		051715	2	NUT HEX M4-0.7 G8 YEL CHR
			KW ONLY)	60		0C7605	2	SCREW HHC M5-0.8 X 60 G8.8
	0E1529	1	CIRCUIT BREAKER 35 X 1 (7.5 KW	61		083049	1	ASY POTTED REG W/FIN
			ONLY)	62		089047	2	SPACER .25 X .43 X .55 ST/ZNC
26	090144	1	CIRCUIT BREAKER 20 X 1 (5.5 KW	63		075234	1	RESISTOR WW LUG 1R 5% 25W
			ONLY)	64		0A2053	1	SCREW HHC M6-1.0 X 65 G8.8
	090145	1	CIRCUIT BREAKER 30 X 1 (6.5 KW	65		058000K	2	NUT TRIC M5 X .8
			ONLY)	66		0D8941	1	COMPARTMENT, AIR BOX
	0E1529	1	CIRCUIT BREAKER 35 X 1 (7.5 KW	67		029451A	2.3 FT.	TAPE, 1/2" X 1/16" CLOSED CELL
			ONLY)	68		0E0583	1	WIRE HARNESS, QP RV (GASOLINE
27	025105	4	SCREW RHM 6-32 X 1/4 SIMS					ONLY)(NOT SHOWN)
28	0A9611	1	FUSE 7.5 AMP			0E1812	1	WIRE HARNESS, QP RV (LP ONLY)
29	032300	1	HOLDER FUSE					(NOT SHOWN)
30	092113	1	SWITCH SPDT ON-MOM-ON	69		0E1375	1	WIRE ASS'Y STARTER TO C/PNL
31	087798	1	SWITCH 6A SPDT					(NOT SHOWN)

Page 79