Manuals
/
Jackson
/
Kitchen Appliance
/
Dishwasher
Jackson
200S, 200LT, 200B
technical manual
Section Parts Section
Models:
200B
200LT
200
200S
1
32
57
57
Download
57 pages
11.25 Kb
29
30
31
32
33
34
35
36
Specifications
Section Electrical Schematics
FAN Load on Timer Output
Maintenance
Parts Section TUB Assembly
Section Service Procedures
Temperatures
Page 32
Image 32
SECTION 6:
PARTS SECTION
27
Page 31
Page 33
Page 32
Image 32
Page 31
Page 33
Contents
Technical Manual
Steam Heated Models
Page
Revision Made Applicable Details Date ECN
200 NB
Nomenclature for the Models Covered in this Manual
Table of Contents Section Description Specifications
II. INSTALLATION/OPERATION Instructions
VII Electrical Diagrams
DRAWING/PARTS Section
Section Specification Information
Temperatures
Operating Cycle Seconds
Tank Capacity Gallons
Wash Pump Capacity
Specification Information Dimensions
TOP View
Corner Conversion TOP View Front
Front View
Specification Information
Table Dimensions
Section INSTALLATION/OPERATION Instructions
Raise Lower Frame with Adjustable Foot
GND
INSTALLATION/OPERATION Instructions Detergent Control
INSTALLATION/OPERATION Instructions Operation Instructions
INSTALLATION/OPERATION Instructions Operation Instructions
Section Preventative Maintenance
Preventative Maintenance
Section Troubleshooting Section
Troubleshooting Section Common Problems
Problem Dishmachine will not run. No power to the unit
Problem Water temperature is less than required
Section Service Procedures
Service Procedures Rinse Solenoid Valve Repair Parts KIT
Steps
Preparation
Tools Required
Prying open the coil wire cover
Removing the valve bonnet
After Maintenance Actions
Special Parts
Service Procedures Vacuum Breaker Repair Parts KIT
Set the cap to the side
Removing the plunger
Service Procedures Rinse Regulating Thermostat Replacement
Service Procedures Rinse Regulating Thermostat Replacement
Tightening the brass fitting
Special Notes
Contact Information
Section Parts Section
Parts Section Control BOX Assembly
Jackson
QTY Description
Parts Section Hood Assembly Single Piece Weldment
Parts Section Cantilever ARM/DOOR Assemblies
Parts Section
Parts Section TUB Assembly
See page Entitled Wash HEATERS/RINSE Heaters
Tub Weldment Not used on 200S
Parts Section Rinse Tank Assembly 200B
Parts Section Wash HEATERS/RINSE Heaters
Rinse Heater 12 KW
Parts Section Motor Assembly
Model Volts Phase Wash Motor Assembly
Parts Section Frame Assembly
Parts Section Incoming Fill PLUMBING/OUTLET Plumbing
Water Pressure Regulator KIT Wprk Option Plumbing
Complete Vacuum Breaker Assembly
Parts Section Coil Assembly 200S
Parts Section Incoming Steam Plumbing Assembly 200S
Parts Section Wash & Rinse ARM/MANIFOLD Assemblies
Exploded View of Wash & Rinse Spindle Assembly
Parts Section Safety Door Interlock SDI Option
FAN Load on Timer Output
Parts Section Exhaust FAN Control Option
Parts Section False Panel Installation
False panel positioned in unit
Section Electrical Schematics
Electricalschematics
200/200B/200LT 208-230-460V, 50/60 HZ, Single & Three Phase
200S 208-230-460V, 50/60 HZ, Single & Three Phase
Top
Page
Image
Contents
