![](/images/new-backgrounds/1058516/585165x1.webp)
Table of Contents | 3 |
Introduction |
|
Introduction | 2 |
Important Information | 2 |
Safety Precautions |
|
Safety Precautions | 4 |
Specifications |
|
Heating Specifications | 6 |
Dimensions | 6 |
Electrical Specifications | 6 |
Fuel | 6 |
EPA Compliance | 6 |
Installation |
|
Before you Begin | 7 |
Packing List | 7 |
Installation Options | 7 |
Planning the Installation | 7 |
Minimum Fireplace Size | 7 |
Hopper Extension | 8 |
Clearances | 10 |
Mantel Requirements | 10 |
Hearth Requirements | 10 |
Facing Requirements | 10 |
Placing the Insert | 10 |
Venting the Pellet Stove | 11 |
Maximum Venting Distance | 11 |
Pellet Vent Type | 11 |
Installing the Pellet Vent | 11 |
Pellet Vent Termination | 11 |
Mobile Home Requirements | 12 |
Outside Air | 12 |
Restrictor Adjustment | 13 |
Baffle Installation | 13 |
Surround Panel & Circuit Board Installation | 14 |
Installation into a Masonry Fireplace | 15 |
Installation into a Factory Built (Metal) Fireplace | 16 |
Operation |
|
Safety Notice | 17 |
Location of Controls | 17 |
Starting the Heater for the First Time | 17 |
Curing the Paint | 17 |
Priming the Auger | 17 |
Loading Pellets | 18 |
The Two Modes of Operation | 18 |
Operation (continued) |
|
Manual Mode | 19 |
Auto Mode | 20 |
Restrictor Adjustment | 21 |
Adjusting the Fan Speed | 21 |
21 | |
"AUGER ON" Light | 21 |
"FAULT" Light | 22 |
Power Outages | 22 |
Maintenance |
|
Daily Maintenance (whenever using the heater) | 23 |
Inspect the Burn | 23 |
Make Sure Pellets are not Piling Up | 23 |
Check Firepot for Clinkers | 24 |
Cleaning the Firepot | 24 |
25 | |
Clean the Heat Exchange Tubes | 25 |
Vacuum Hopper | 25 |
Clean the Plated Surfaces | 25 |
Opening the Door | 26 |
Check Ashbox and Ashpan, Dispose | 27 |
Clean the Glass | 27 |
Sweep Ash Into Ashpan | 28 |
Yearly Maintenance (or every two tons) | 29 |
Clean the Exhaust Duct | 29 |
Clean the Exhaust Blower | 30 |
Clean the Vent | 30 |
Door Seal | 31 |
Door Alignment | 31 |
Adjusting the Door Hinge and Latch | 32 |
Check for Air Leaks - Door, Glass and Ashpan .... | 33 |
Replacement Parts | 33 |
Normal Operating Sounds |
|
Normal Operating Sounds | 34 |
Safety Label |
|
Safety Label | 35 |
Warranty |
|
Warranty | 36 |
Optional Equipment |
|
Thermostat | 37 |
Remote Thermostat | 38 |
Optional Log | 38 |
Optional Door and Grill | 38 |
ZC Kit | 39 |
Index |
|
Index | 40 |
Travis Industries | 4 0 5 0 5 0 9 | 1 0 0 - 0 1 1 4 5 |