Miller Electric Renegade 180 manual Parts List, Recommended Spare Parts

	. Complete Parts List available at www. MillerWelds.com
Trouble	Remedy
Engine will not start.	Check fuel level (see Section 5-3).
	Move choke control to correct position (see Section 6-1).
	Open fuel valve (see Section 5-3). Close fuel valve before moving unit or carburetor may flood and make
	starting difficult.
	Be sure engine switch is On.
	Check oil level (see Section 5-3). Engine stops if oil level is too low. Refill crankcase with proper viscosity
	oil for operating temperature.
	Have Factory Authorized Service Agent check low oil level shutdown switch.
	Check battery voltage (electric start models only).
	Check battery connections and tighten if necessary (electric start models only).
Engine stopped during normal	Check fuel level (see Section 5-3).
operation.
	Open fuel valve (see Section 5-3). Close fuel valve before moving unit or carburetor may flood and make
	starting difficult.
	Check oil level (see Section 5-3). Engine stops if oil level is too low.
Unstable or sluggish engine speeds.	Check engine speed, and adjust if necessary (see Section 8-10).
	Check throttle/governor linkage for smooth, non-binding operation.
	Tune-up engine according to engine manual.
Battery discharges between uses (Elec-	Clean battery terminals and posts with baking soda and water solution; rinse with clear water.
tric Start Models Only).
	Periodically recharge battery (approximately every 3 months).
	Replace battery.
	Check engine battery charging circuit and connections according to engine manual.

SECTION 10 − PARTS LIST

.A complete parts list is available at www.MillerWelds.com.

10-1. Recommended Spare Parts

Part	Description	Quantity
No.
	Recommended Spare Parts
. . . . . . . . . . . 221581	. . Tune−up & Filter Kit, Kohler (Includes)	. . . 1
. . . . . . . . . . . 203960	. . Spark Plug, Kohler (CS8/10/12)	. . . 1
. . . . . . . . . . . 221579	. . Air Filter, Kohler (CS10−recoil)	. . . 1
. . . . . . . . . . . 221580	. . Air Filter Pre−cleaner, Kohler (CS10−recoil)	. . . 1
. . . . . . . . . . . 169715	. . Nozzle, Slip Type .500 Orf Flush	. . . 1
. . . . . . . . . . . 087299	. . Tip, Contact Scr .023 Wire X 1.125	. . . 1
. . . . . . . . . . . 000067	. . Tip, Contact Scr .030 Wire X 1.125	. . . 1
. . . . . . . . . . . 000068	. . Tip, Contact Scr .035 Wire X 1.125	. . . 1
. . . . . . . . . . . 000069	. . Tip, Contact Scr .045 Wire X 1.125	. . . 1
. . . . . . . . . . . 194010	. . Liner, Monocoil .023/.025 Wire X 15ft (Consisting Of)	. . . 1
. . . . . . . . . . . . 194011	. . Liner, Monocoil .030/.035 Wire X 15ft (Consisting Of)	. . . 1
. . . . . . . . . . . 194012	. . Liner, Monocoil .035−.045 Wire X 15 ft (Consisting Of)	. . . 1
. . . . . . . . . . . 079975	. . . . O-ring, .187 Id X .103cs Rbr	. . . 1

OM-228 042 Page 40