components (generator)
Figure 4. Generator Components (continued)
15.Engine Oil Drain Plug – Remove this drain plug when draining of the oil from the engine crankcase is required. Fill with recommeded type oil as listed in Table 4
16.Engine Oil Dipstick – Remove oil dipstick to check engine oil level.
17.Fuel Drain Plug – Remove plug to drain fuel.
18.Fuel Gauge – This gauge is located on top of the fuel tank. Read this gauge to determine when fuel is low.
19.Spark Plug – Provides spark to the ignition system. Set spark plug gap to 0.6 - 0.7 mm (0.028 - 0.031 inch) Clean spark plug once a week.
20.Recoil Starter (pull rope) –
21.Fuel Tank/Cap – Remove fuel cap to add fresh unleaded fuel. Fuel tank capacity is 10 gallons (38 liters).
22.Battery – This generator is equipped with a 12 VDC battery. Replace with only recommended type battery.
23.Choke Lever – Used for starting the engine. Close the choke lever when starting a cold engine or in cold weather conditions. The choke enriches the fuel mixture. Open the choke lever if starting a warm engine or in warm weather conditions
24.Muffler/Heat Shield – Used to reduce noise and emissions. NEVER touch this heat shield when the generator/welder is in use. Always allow time for engine to cool before servicing.
25.Oil Filter – Replace oil filter as referenced in maintenance section of this manual.
26.Engine Oil Filler Hole – Remove cap when the adding of engine oil is required. See Table 4 for recommended type engine oil.
27.Air Cleaner – Prevents dirt and other debris from entering the fuel system. Release retaining clips on top of air filter cover to gain access to filter element. NEVER run the engine without an air cleaner.
NOTICE
This HONDA engine is equipped with a low oil
shutdown capability. A built in sensor will automatically turn off the engine should the oil level fall below a safe operating condition. Make sure the generator is placed on level ground. Placing the generator on level ground will ensure that the low oil sensor will function properly.
page 18 — GAC9.7HZ 60 hz gENERATOR• operation and parts manual — rev. #2 (03/31/10)
