![](/images/new-backgrounds/1057825/5782581x1.webp)
S U F S E R V I C E H A N D B O O K
S E R V I C E C H E C K L I S T
SERVICE CHECKLIST
This is not intended to be and
SERVICE AGENT: |
| INSTALLATION DATE: |
|
| |||||||
MODEL NUMBER: |
|
|
|
| SERVICE DATE: |
|
|
|
| ||
SERIAL NUMBER: |
|
|
|
| LOCATION ADDRESS: |
|
| ||||
|
|
|
|
|
| ||||||
|
|
|
|
|
| PHONE | ( | ) |
|
|
|
GAS | TYPE — CHECK ONE |
| - |
| |||||||
|
|
|
|
|
|
| |||||
| NATURAL |
|
|
|
|
|
|
| |||
| PROPANE |
|
| YES | NO |
|
|
|
| ||
| PROPER GAS VALUE VERIFIED |
|
|
|
|
|
I.CHECK CLEARANCE (CIRCLE ANSWER)
A. | Are exterior clearances adequate? |
| yes | no | |
B. | Are interior clearances adequate? |
| yes | no | |
| |||||
| Comments: |
|
|
|
|
|
|
|
|
II.CHECK MAKEUP AIR REQUIREMENTS
A. | Is the quality of |
| yes | no | |
B. | Comments: |
|
| yes | no |
|
|
| |||
Is the quantity of |
| ||||
| Comments: |
|
|
|
|
|
|
|
|
III.GAS PRESSURE (FILL IN BLANK) — ALL UNITS ON.
A.Supply gas pressure __ inches of W.C. (flowing)
B.Manifold gas pressure (main burner) __ inches of W.C. (flowing) Comments:
IV. | VENTING (CHECK) |
|
|
|
| yes | no | |
| A. | Acceptable equivalent footage | ||||||
| B. | Proper material |
|
|
| yes | no | |
|
|
|
| |||||
| C. | Proper exterior installation |
|
|
| yes | no | |
|
|
|
| |||||
| D. | Condensate will drain |
|
|
| yes | no | |
|
|
|
| |||||
|
| Comments: |
|
|
|
|
| |
|
|
|
|
|
|
| ||
V. | WATER PIPING |
|
|
| yes | no | ||
|
|
| ||||||
| Is the system properly sized? | |||||||
| Is the system properly installed? |
|
|
| yes | no | ||
|
|
|
| |||||
| Are there any water leaks? |
|
|
| yes | no | ||
|
|
|
| |||||
| Does the installation have a recirculating system? |
|
|
| yes | no | ||
|
|
|
| |||||
| If so, is it operational? |
|
|
| yes | no | ||
|
|
|
| |||||
VI. | SAFETY |
|
|
|
|
| ||
|
|
|
|
| ||||
| A. | Air | yes | no | ||||
|
| If exhaust is blocked will unit lockout? | ||||||
|
| If air intake is blocked will unit lockout? |
|
|
| yes | no | |
|
|
|
|
| ||||
| B. | Water Temperature |
|
|
| yes | no | |
|
|
|
| |||||
|
| - Is the thermostat adjusted to the lowest acceptable temperature? | ||||||
|
| - Does the installation have a mixing valve? |
| yes | no | |||
|
|
| ||||||
|
| - If so, is it operational? |
|
| yes | no | ||
|
|
|
| |||||
|
| - What is the outlet temperature of the mixing valve? |
|
| yes | no | ||
|
|
|
| |||||
NOTE: To minimize the risk of scalding, the manufacturer recommends |
|
|
|
| ||||
storing water at 120° F. | yes | no | ||||||
| Is a properly rated temperature and pressure relief valve installed? | |||||||
| Is there a properly installed expansion tank? |
| yes | no | ||||
|
| |||||||
| Should there be? |
| yes | no | ||||
|
| |||||||
| C. | Electrical |
| yes | no | |||
|
| Is the 120 VAC electrical powers supply properly wired? (including polarity) |
| |||||
|
|
| ||||||
|
| Are all the SUF control covers in place? |
| yes | no | |||
|
|
| ||||||
|
| Is the 120 VAC electrical power supply properly fused? |
| yes | no | |||
|
|
| ||||||
| D. | Flammables |
| yes | no | |||
|
| |||||||
|
| Are flammable materials located in the area of the water heater? or air intake? | ||||||
|
| Are flammable vapors located in the area of the water heater? or air intake? |
| yes | no | |||
|
|
|
E.Gas
| If the gas supply is reduced or turned off will the unit turn off? |
| yes | no | |
| Comments: |
|
|
|
|
| [This service checklist |
|
|
|
|
| may be photo copied to assist with SUF service calls.] |
|
|
| |
Technical Training Department | 40 | State Water Heaters | |||
| Ashland City, Tennessee © 2004 |