Generac 004373-2, 004626-1, 004626-1, 004373-2 owner manual Exploded Views and Parts Lists

Page 40

Section 7 — Exploded Views and Parts Lists

(Model Nos. 004373-2 & 004626-1) Guardian Liquid-cooled 40 kW Generators Engine Parts – Drawing No. 0D6980-A

38 Generac® Power Systems, Inc.

Image 40

Contents Power SYSTEMS, INC Introduction Authorized Dealer LocationSafety Rules General Information InstallationMaintenance Section Installation Drawings 56-57 Warranty Back CoverGeneral Hazards Electrical Hazards Prepackaged Transfer Switch UNPACKING/INSPECTIONGenerator Generator AC Connection SystemsMain Circuit Breaker SpecificationsEngine Protective Devices Fuel Requirements Recommendations Generator and Load CompatibilityEngine Conversion to LP GAS VaporEmissions Control System CoolantAIR Fuel Ratio Controller Standby Generator Installation Basic Standby Electric SystemNfpa Standards Other Published StandardsTransfer Switch Start Signal Connections Pre-Packaged Type SwitchGTS Type Engineered Switch Emergency Circuit Isolation MethodPreparation Before START-UP Battery InstallationVented Batteries Prior to Initial START-UP Using the AUTO/OFF/MANUAL Switch OFF Position Manual PositionAutomatic Transfer Operation Sequence of Automatic OperationWeekly Exercise Cycle Checking the Engine OIL LevelOil and Filter Change Procedure Changing the Engine AIR CleanerChanging the Engine OIL and Filter Engine Oil RecommendationsBattery Maintenance Spark PlugsMiscellaneous Maintenance Cleaning the GeneratorOverload Protection for Engine DC Electrical System DC FuseRemoval From Service OUT of Service ProcedureReturn To Service Service Schedule SYSTEM/COMPONENT Procedure FrequencyTroubleshooting Guide Problem Cause CorrectionElectrical Data Section Generac Generac Power Systems,Inc Electrical Data Electrical Data Electrical Data Wiring Diagram Customer Connection Power Systems Inc HRSPart NO. QTY. Description Generators Part NO. QTY Description Part NO.QTY Description QTY Description 4640 31 33 Part NO.QTY. Description Washer Flat 3/8-M10 ZincExploded Views and Parts Lists Flywhl 4.3L GM SAE Stator Leads Scrolldetail To Engine Flywheel QTY Description Part NO. QTY Assembly Cover Access Description QTYRadiator Copper Brass Gasket Carburetor Adaptor Gasket Carb Impco QTY. Description To CarburetorSupport Solenoid NAT GAS QTY. Description To Starter Solenoid RED Black To Engine Block ALT Leads Sensing Wire Siemens FD 3 Pole QTY Description Exploded Views and Parts Lists Part NO. QTY. Description Muffler 2-1/2 INLET/OUTLET Guardian Liquid-cooled 40 kW Generators Installation Drawings 12V Battery see Note Lifting EYE Places Warranty Schedule This Warranty Shall not Apply to the Following