Generac 004373-2, 004626-1, 004626-1, 004373-2 owner manual QTY. Description

Page 50

Section 7 — Exploded Views and Parts Lists

(Model Nos. 004373-2 & 004626-1) Guardian Liquid-cooled 40 kW Generators

Engine Coolant Heater – Drawing No. 087434-D

Lower Radiator To Water
Hose			Pump		To Engine
To Lower		1
	2		3	14	Block
Radiator

7

3

6

5

13

3

11

3

4

11

91010

812

ITEM	PART NO.	QTY. DESCRIPTION
1	080723	1	HOSE CONNECTION TEE 1.75-.62
2	035685	2	CLAMP, HOSE #28 1.32-2.25
3	057822	4	CLAMP, HOSE #8 .53-1.00
4	084918C	1	HEATER, ENGINE 1800W 120V.
	*084918D	1	HEATER, ENGINE 2000W 240V.
5	050967	1	HOSE, 5/8" I.D. RIA 250F (36”)
6	0A6283	1	HOSE, PREFORMED BLOCK HEATER
7	053660	1	BARBED ST. 1/4" NPT x 5/8 I.D.
8	084427	1	BRACKET, HEATER
9	047411	2	SCREW HHC M6-1.0 X 16 G8.8
10	022097	4	WASHER, LOCK-M6-1/4
11	022473	4	WASHER, FLAT 1/4 ZINC
12	049813	2	NUT, HEX-M6 X 1.00 G8 YEL CHR
13	042568	2	SCREW, HHC-M6-1.0 x 20MM G8.8
14	**077043E	36"	FLEXIBLE CONDUIT 1" BLACK

*USED ON "R" VOLTAGE GENERATORS ONLY **ITEM #14 USED ONLY ON 4.3L UNITS

48 Generac® Power Systems, Inc.

Image 50

Contents Power SYSTEMS, INC Introduction Authorized Dealer LocationMaintenance Safety Rules General InformationInstallation Section Installation Drawings 56-57 Warranty Back CoverGeneral Hazards Electrical Hazards Generator Prepackaged Transfer SwitchUNPACKING/INSPECTION Generator AC Connection SystemsEngine Protective Devices SpecificationsMain Circuit Breaker Engine Fuel Requirements RecommendationsGenerator and Load Compatibility Conversion to LP GAS VaporAIR Fuel Ratio Controller CoolantEmissions Control System Nfpa Standards Standby Generator InstallationBasic Standby Electric System Other Published StandardsGTS Type Engineered Switch Transfer Switch Start Signal ConnectionsPre-Packaged Type Switch Emergency Circuit Isolation MethodVented Batteries Battery InstallationPreparation Before START-UP Prior to Initial START-UP Using the AUTO/OFF/MANUAL Switch Automatic Transfer Operation OFF PositionManual Position Sequence of Automatic OperationWeekly Exercise Cycle Checking the Engine OIL LevelChanging the Engine OIL and Filter Oil and Filter Change ProcedureChanging the Engine AIR Cleaner Engine Oil RecommendationsBattery Maintenance Spark PlugsOverload Protection for Engine DC Electrical System Miscellaneous MaintenanceCleaning the Generator DC FuseReturn To Service OUT of Service ProcedureRemoval From Service Service Schedule SYSTEM/COMPONENT Procedure FrequencyTroubleshooting Guide Problem Cause CorrectionElectrical Data Section Generac Generac Power Systems,Inc Electrical Data Electrical Data Electrical Data Wiring Diagram Customer Connection Power Systems Inc HRSPart NO. QTY. Description Generators Part NO. QTY Description Part NO.QTY Description QTY Description 4640 31 33 Part NO.QTY. Description Washer Flat 3/8-M10 ZincExploded Views and Parts Lists Flywhl 4.3L GM SAE Stator Leads Scrolldetail To Engine Flywheel QTY Description Part NO. QTY Assembly Cover Access Description QTYRadiator Copper Brass Gasket Carburetor Adaptor Gasket Carb Impco QTY. Description To CarburetorSupport Solenoid NAT GAS QTY. Description To Starter Solenoid RED Black To Engine Block ALT Leads Sensing Wire Siemens FD 3 Pole QTY Description Exploded Views and Parts Lists Part NO. QTY. Description Muffler 2-1/2 INLET/OUTLET Guardian Liquid-cooled 40 kW Generators Installation Drawings 12V Battery see Note Lifting EYE Places Warranty Schedule This Warranty Shall not Apply to the Following