Briggs & Stratton 30235 operating instructions Operation, Starting the Engine

Page 11

Operation

Starting the Engine

Disconnect all electrical loads from the generator. Use the following start instructions:

1. Make sure unit is on a level surface.

IMPORTANT: Failure to start and operate the unit on a level surface will cause the unit not to start or shut down during operation.

2.Turn red fuel valve from “Off” position (A) to “On” position (B) (Figure 7).

A B

Figure 7 — Fuel Valve

A - “Off” Position

B - “On” Position

3. Push choke lever to “Choke” position (Figure 8).

Figure 8 — Choke Lever

4. Push engine rocker switch to “On” (Figure 9).

Figure 9 — Engine Rocker Switch

5.Grasp recoil handle and pull slowly until slight resistance is felt. Then pull handle rapidly to overcome compression, prevent kickback, and start engine.

WARNING

Rapid retraction of starter cord (kickback) will pull hand and arm toward engine faster than you can let go.

Broken bones, fractures, bruises or sprains could result.

•When starting engine, pull cord slowly until resistance is felt and then pull rapidly to avoid kickback.

•NEVER start or stop engine with electrical devices plugged in and turned on.

IMPORTANT: If excessive fuel is present in the air/fuel mixture causing a “flooded” condition, move the choke lever to “Run” () position and pull the handle repeatedly until the engine starts.

6.Move choke lever to “Run” () position a short distance at a time over several seconds in warm weather or minutes in cold weather. Let engine run smoothly before each change. Operate with choke in “Run” position.

WARNING

Running engines produce heat. Temperature of muffler and nearby areas can reach or exceed 150°F (65°C).

Severe burns can occur on contact.

Exhaust heat/gases can ignite combustibles, structures or damage fuel tank causing a fire.

•DO NOT touch hot surfaces and avoid hot exhaust gases.

•Allow equipment to cool before touching.

•Keep at least 5 ft. (152 cm) clearance on all sides of generator including overhead.

•Code of Federal Regulation (CFR) Title 36 Parks, Forests, and Public Property require equipment powered by an internal combustion engine to have a spark arrester, maintained in effective working order, complying to USDA Forest service standard 5100-1C or later revision. In the State of California a spark arrester is required under section 4442 of the California Public resources code. Other states may have similar laws.

NOTE: If the engine starts after 3 pulls but fails to run, or if the unit shuts down during operation, make sure the unit is on a level surface and check for the proper oil level in the crankcase. This unit may be equipped with a low oil protection device.

9

Page 10 Page 12
Image 11
Page 10 Page 12
Contents Watts Revision Serial Number Engine Model Number Date Purchased Where to Find UsTable of Contents Hazard Symbols and Meanings Safety RulesWhen transporting or repairing equipment When adding or draining fuelWhen starting equipment When operating equipmentEquipment Description AssemblyShipment Contents Install Wheel KitFuel must meet these requirements When adding fuelAdd Engine Oil Add FuelSpecial Requirements Connecting to a Building’s Electrical SystemSystem Ground Generator LocationFeatures and Controls 120/240 Volt AC, 30 Amp, Locking Receptacle ReceptaclesNema L14-30 Generator Adapter Cord SetStarting the Engine OperationStopping the Engine Connecting Electrical LoadsExample Power ManagementDon’t Overload Generator CapacityEmissions Control MaintenanceMaintenance Schedule General RecommendationsOil Recommendations Generator MaintenanceCleaning OilChanging Engine Oil Checking Oil LevelAdding Engine Oil Clean Spark Arrester Screen Service Air CleanerService Spark Plug Check Valve Clearance Carburetor AdjustmentClean and inspect the spark arrester as follows Engine Air Cooling SystemStorage Troubleshooting Engine Technical Information SpecificationsReplacement Parts Maintenance ItemsLength of Coverage Owner’s Warranty ResponsibilitiesWarranted Parts Claims and Coverage Exclusions Maintenance Consequential CoverageNo Charge Warranty Period This page reserved Dónde encontrarnos Controles y características Resolución de problemas Especificaciones GarantíasReglas de seguridad MontajeSímbolos de peligro y sus significados Normas de seguridadCuando transporte o repare el equipo Cuando anada combustible o vacíe el depósitoCuando ponga en funcionamiento el equipo Cuando opere el equipoContenido de la caja MontajeDescripción del equipo Desembalaje del generadorGran altitud Agregar aceite al motorAgregue combustible Cuando anada combustibleRequisitos Especiales Tierra del sistemaConexión al sistema eléctrico de un edificio Ubicación del generadorControles y características del generador Juego de cables del adaptador del generador Tomas eléctricasTomas eléctricas dobles de 120 V CA y 20 a Dispositivo de seguridad de 120/240 V, 30 aEncienda el motor OperandoParada del motor Conexión de cargas eléctricasControl de la energía No sobrecargar el generadorCapacidad EjemploControl de emisiones MantenimientoPlan de mantenimiento Recomendaciones GeneralesRecomendaciones sobre el aceite Mantenimiento del GeneradorLimpieza AceiteCambio de Aceite del Motor Comprobación del Nivel de AceiteAdición de Aceite del Motor Limpie la Pantalla Apagachispas Servicio del depurador de aireServicio del bujía Limpie e inspeccione el apagachispas de la siguiente manera Sistema de refrigeración de aireComprobación de holgura de la válvula Ajuste del CarburadorAlmacenamiento Problemo Causa Accion Resolución de problemasEspecificaciones del Motor Información Técnica Sobre el MotorPotencia Nominal Especificaciones del GeneradorDuración de la cobertura Responsabilidades de la garantía del propietarioPiezas garantizadas Cobertura de daños derivados Servicio gratuitoSolicitudes y exclusiones de cobertura MantenimientoPeríodo DE Garantía

30235 specifications

The Briggs & Stratton 30235 is a powerful and efficient portable generator designed to provide reliable backup power. Ideal for homeowners and recreational users alike, this model boasts a range of features and technologies that enhance its performance and usability.

One of the standout features of the Briggs & Stratton 30235 is its 306cc engine, which delivers 7,000 starting watts and 5,500 running watts. This robust power output ensures that essential appliances, tools, and devices can be effectively supported during power outages or when on outdoor adventures. The generator is equipped with a durable 4-gallon metal fuel tank, providing up to 13 hours of run time at 50% load, which means users can count on extended operation without frequent refueling.

The generator employs a reliable and user-friendly design, featuring an easy-to-read LED display that provides important information such as power output and operational status. Additionally, it includes an automatic low oil shutdown feature, which protects the engine from damage by shutting down the unit when oil levels are too low. This functionality not only prolongs the life of the generator but also assists users in maintaining optimal performance.

For enhanced portability, the Briggs & Stratton 30235 comes with a built-in handle and never-flat wheels, making it easy to transport and position wherever needed. Its compact footprint allows it to be stored without taking up excessive space, making it an ideal choice for those with limited storage options.

The generator also features multiple outlets, including 120V 20A NEMA 5-20R duplex receptacles and a 120/240V 30A L14-30R lockable receptacle. This versatility allows users to connect a variety of devices and appliances, enhancing its usability for different applications, from home backup to camping trips.

In terms of safety, the Briggs & Stratton 30235 includes circuit protection to prevent overloading, ensuring that connected devices are protected. Moreover, it runs quietly compared to many other generators in its class, making it suitable for use in residential areas without causing a disturbance.

Overall, the Briggs & Stratton 30235 combines power, portability, and practicality, making it a top choice for those in need of reliable backup power or portable energy solutions. With its thoughtful design and advanced features, this generator stands out as a dependable companion for any situation that requires consistent electrical support.
Top Page Image Contents