Briggs & Stratton 30235 operating instructions Troubleshooting

Page 20

Troubleshooting

Problem

Cause

Correction

 

1.

One of the circuit breakers is open.

1.

Reset circuit breaker.

 

2.

Fault in generator.

2.

Contact authorized service facility.

Engine is running, but no

3.

Poor connection or defective cord

3.

Check and repair.

AC output is available.

 

set.

 

 

 

4.

Connected device is bad.

4.

Connect another device that is in

 

 

 

 

good condition.

 

 

 

 

 

 

1.

Short circuit in a connected load.

1.

Disconnect shorted electrical load.

Engine runs good at no-

2.

Engine speed is too slow.

2.

Contact authorized service facility.

load but "bogs down"

3.

Generator is overloaded.

3.

See Don't Overload Generator in

when loads are connected.

 

 

 

the Operation section.

 

4.

Shorted generator circuit.

4.

Contact authorized service facility.

 

 

 

 

 

 

1.

Rocker switch set to "Off".

1.

Set switch to "On".

 

2.

Fuel Valve is in "Off" position.

2.

Turn fuel valve to "Open" position.

 

3.

Dirty air cleaner.

3.

Clean or replace air cleaner.

 

4.

Out of fuel.

4.

Fill fuel tank.

 

5.

Stale fuel.

5.

Drain fuel tank and carburetor; fill

 

 

 

 

with fresh fuel.

 

6.

Spark plug wire not connected to

6.

Connect wire to spark plug.

Engine will not start; or

 

spark plug.

 

 

starts and runs rough.

7.

Bad spark plug.

7.

Replace spark plug.

 

8.

Water in fuel.

8.

Drain gas tank and carburetor; fill

 

 

 

 

with fresh fuel.

 

9.

Flooded.

9.

Wait 5 minutes and re-crank

 

 

 

 

engine.

 

10.

Excessively rich fuel mixture.

10.

Contact authorized service facility.

 

11.

Intake valve stuck open or closed.

11.

Contact authorized service facility.

 

12.

Engine has lost compression.

12.

Contact authorized service facility.

 

 

 

Engine shuts down when

Out of fuel.

Fill fuel tank.

running.

 

 

 

 

 

 

 

 

 

 

1.

Load is too high.

1.

See Don't Overload Generator in

Engine lacks power.

 

 

 

the Operation section.

 

2.

Dirty air filter.

2.

Replace air filter.

 

 

 

Engine "hunts" or falters.

Carburetor is running too rich or too

Contact authorized service facility.

lean.

 

 

 

 

 

 

 

 

 

 

18BRIGGSandSTRATTON.com

Page 19 Page 21
Image 20
Page 19 Page 21
Contents Watts Where to Find Us Revision Serial Number Engine Model Number Date PurchasedTable of Contents Safety Rules Hazard Symbols and MeaningsWhen adding or draining fuel When starting equipmentWhen operating equipment When transporting or repairing equipmentAssembly Shipment ContentsInstall Wheel Kit Equipment DescriptionWhen adding fuel Add Engine OilAdd Fuel Fuel must meet these requirementsConnecting to a Building’s Electrical System System GroundGenerator Location Special RequirementsFeatures and Controls Receptacles Nema L14-30Generator Adapter Cord Set 120/240 Volt AC, 30 Amp, Locking ReceptacleOperation Starting the EngineConnecting Electrical Loads Stopping the EnginePower Management Don’t Overload GeneratorCapacity ExampleMaintenance Maintenance ScheduleGeneral Recommendations Emissions ControlGenerator Maintenance CleaningOil Oil RecommendationsChanging Engine Oil Checking Oil LevelAdding Engine Oil Clean Spark Arrester Screen Service Air CleanerService Spark Plug Carburetor Adjustment Clean and inspect the spark arrester as followsEngine Air Cooling System Check Valve ClearanceStorage Troubleshooting Specifications Replacement PartsMaintenance Items Engine Technical InformationLength of Coverage Owner’s Warranty ResponsibilitiesWarranted Parts Claims and Coverage Exclusions Maintenance Consequential CoverageNo Charge Warranty Period This page reserved Dónde encontrarnos Resolución de problemas Especificaciones Garantías Reglas de seguridadMontaje Controles y característicasNormas de seguridad Símbolos de peligro y sus significadosCuando anada combustible o vacíe el depósito Cuando ponga en funcionamiento el equipoCuando opere el equipo Cuando transporte o repare el equipoMontaje Descripción del equipoDesembalaje del generador Contenido de la cajaAgregar aceite al motor Agregue combustibleCuando anada combustible Gran altitudTierra del sistema Conexión al sistema eléctrico de un edificioUbicación del generador Requisitos EspecialesControles y características del generador Tomas eléctricas Tomas eléctricas dobles de 120 V CA y 20 aDispositivo de seguridad de 120/240 V, 30 a Juego de cables del adaptador del generadorOperando Encienda el motorConexión de cargas eléctricas Parada del motorNo sobrecargar el generador CapacidadEjemplo Control de la energíaMantenimiento Plan de mantenimientoRecomendaciones Generales Control de emisionesMantenimiento del Generador LimpiezaAceite Recomendaciones sobre el aceiteCambio de Aceite del Motor Comprobación del Nivel de AceiteAdición de Aceite del Motor Limpie la Pantalla Apagachispas Servicio del depurador de aireServicio del bujía Sistema de refrigeración de aire Comprobación de holgura de la válvulaAjuste del Carburador Limpie e inspeccione el apagachispas de la siguiente maneraAlmacenamiento Resolución de problemas Problemo Causa AccionInformación Técnica Sobre el Motor Potencia NominalEspecificaciones del Generador Especificaciones del MotorDuración de la cobertura Responsabilidades de la garantía del propietarioPiezas garantizadas Servicio gratuito Solicitudes y exclusiones de coberturaMantenimiento Cobertura de daños derivadosPeríodo DE Garantía

30235 specifications

The Briggs & Stratton 30235 is a powerful and efficient portable generator designed to provide reliable backup power. Ideal for homeowners and recreational users alike, this model boasts a range of features and technologies that enhance its performance and usability.

One of the standout features of the Briggs & Stratton 30235 is its 306cc engine, which delivers 7,000 starting watts and 5,500 running watts. This robust power output ensures that essential appliances, tools, and devices can be effectively supported during power outages or when on outdoor adventures. The generator is equipped with a durable 4-gallon metal fuel tank, providing up to 13 hours of run time at 50% load, which means users can count on extended operation without frequent refueling.

The generator employs a reliable and user-friendly design, featuring an easy-to-read LED display that provides important information such as power output and operational status. Additionally, it includes an automatic low oil shutdown feature, which protects the engine from damage by shutting down the unit when oil levels are too low. This functionality not only prolongs the life of the generator but also assists users in maintaining optimal performance.

For enhanced portability, the Briggs & Stratton 30235 comes with a built-in handle and never-flat wheels, making it easy to transport and position wherever needed. Its compact footprint allows it to be stored without taking up excessive space, making it an ideal choice for those with limited storage options.

The generator also features multiple outlets, including 120V 20A NEMA 5-20R duplex receptacles and a 120/240V 30A L14-30R lockable receptacle. This versatility allows users to connect a variety of devices and appliances, enhancing its usability for different applications, from home backup to camping trips.

In terms of safety, the Briggs & Stratton 30235 includes circuit protection to prevent overloading, ensuring that connected devices are protected. Moreover, it runs quietly compared to many other generators in its class, making it suitable for use in residential areas without causing a disturbance.

Overall, the Briggs & Stratton 30235 combines power, portability, and practicality, making it a top choice for those in need of reliable backup power or portable energy solutions. With its thoughtful design and advanced features, this generator stands out as a dependable companion for any situation that requires consistent electrical support.
Top Page Image Contents