Briggs & Stratton 30235 Assembly, Equipment Description, Unpack Generator, Shipment Contents

Page 6

Equipment Description

Read this manual carefully and become familiar with your generator. Know its applications, its limitations and any hazards involved.

The generator is an engine–driven, revolving field, alternating current (AC) generator. It was designed to supply electrical power for operating compatible electrical lighting, appliances, tools and motor loads. The generator’s revolving field is driven at about 3,600 rpm by a single-cylinder engine.

Every effort has been made to ensure that the information in this manual is both accurate and current. However, the manufacturer reserves the right to

change, alter or otherwise improve the generator and this documentation at any time without prior notice.

NOTICE

Exceeding generators wattage/amperage capacity can damage generator and/or electrical devices connected to it.

•DO NOT exceed the generator’s wattage/amperage capacity. See Don’t Overload Generator in the Operation section.

The Emission Control System for this generator is warranted for standards set by the Environmental Protection Agency and the California Air Resources Board.

Assembly

Your generator requires some assembly and is ready for use after it has been properly serviced with the recommended fuel and oil level is verified.

If you have any problems with the assembly of your generator, please call the generator helpline at

1-800-743-4115. If calling for assistance, please have the model, revision, and serial number from the data tag available. See Generator Controls and Features for data tag location.

Unpack Generator

1.Set the carton on a rigid, flat surface.

2.Remove everything from carton except generator.

3.Open carton completely by cutting each corner from top to bottom.

4.Leave generator on carton to install wheel kit.

Shipment Contents

The generator is supplied with:

•Operator’s manual

•Adapter cord set

•Wheel kit

Install Wheel Kit

NOTE: Wheel kit is not intended for over-the-road use.

You will need the following tools to install these components:

•13 mm wrench

•Socket wrench with a 13 mm socket

•Pliers

•Safety glasses

Refer to Figure 1 and install the wheel kit as follows:

1a

B

A

C

F A

E

B D

G

Figure 1 — Install Wheel Kit

A - Axle

B - Wheel

C - Flat Washer

D - E-Ring

E - Support Leg

F - M8 x 16 mm Capscrews

G - Hex Nuts

1.Tip generator so that engine end is up.

2.Slide axle (A) through both mounting brackets.

3.Place a wheel (B) on each side as shown in Figure 1a.

4.Place a washer (C) on axle and then place an e-ring (D) in axle groove.

CAUTION

E-rings can cause eye injury.

E-rings can spring back and become airborne when installing or removing.

•Always wear eye protection when installing/removing e-rings.

4BRIGGSandSTRATTON.com

Page 5 Page 7
Image 6
Page 5 Page 7
Contents Watts Where to Find Us Revision Serial Number Engine Model Number Date PurchasedTable of Contents Safety Rules Hazard Symbols and MeaningsWhen operating equipment When adding or draining fuelWhen starting equipment When transporting or repairing equipmentInstall Wheel Kit AssemblyShipment Contents Equipment DescriptionAdd Fuel When adding fuelAdd Engine Oil Fuel must meet these requirementsGenerator Location Connecting to a Building’s Electrical SystemSystem Ground Special RequirementsFeatures and Controls Generator Adapter Cord Set ReceptaclesNema L14-30 120/240 Volt AC, 30 Amp, Locking ReceptacleOperation Starting the EngineConnecting Electrical Loads Stopping the EngineCapacity Power ManagementDon’t Overload Generator ExampleGeneral Recommendations MaintenanceMaintenance Schedule Emissions ControlOil Generator MaintenanceCleaning Oil RecommendationsChecking Oil Level Adding Engine OilChanging Engine Oil Service Air Cleaner Service Spark PlugClean Spark Arrester Screen Engine Air Cooling System Carburetor AdjustmentClean and inspect the spark arrester as follows Check Valve ClearanceStorage Troubleshooting Maintenance Items SpecificationsReplacement Parts Engine Technical InformationOwner’s Warranty Responsibilities Warranted PartsLength of Coverage Maintenance Consequential Coverage No ChargeClaims and Coverage Exclusions Warranty Period This page reserved Dónde encontrarnos Montaje Resolución de problemas Especificaciones GarantíasReglas de seguridad Controles y característicasNormas de seguridad Símbolos de peligro y sus significadosCuando opere el equipo Cuando anada combustible o vacíe el depósitoCuando ponga en funcionamiento el equipo Cuando transporte o repare el equipoDesembalaje del generador MontajeDescripción del equipo Contenido de la cajaCuando anada combustible Agregar aceite al motorAgregue combustible Gran altitudUbicación del generador Tierra del sistemaConexión al sistema eléctrico de un edificio Requisitos EspecialesControles y características del generador Dispositivo de seguridad de 120/240 V, 30 a Tomas eléctricasTomas eléctricas dobles de 120 V CA y 20 a Juego de cables del adaptador del generadorOperando Encienda el motorConexión de cargas eléctricas Parada del motorEjemplo No sobrecargar el generadorCapacidad Control de la energíaRecomendaciones Generales MantenimientoPlan de mantenimiento Control de emisionesAceite Mantenimiento del GeneradorLimpieza Recomendaciones sobre el aceiteComprobación del Nivel de Aceite Adición de Aceite del MotorCambio de Aceite del Motor Servicio del depurador de aire Servicio del bujíaLimpie la Pantalla Apagachispas Ajuste del Carburador Sistema de refrigeración de aireComprobación de holgura de la válvula Limpie e inspeccione el apagachispas de la siguiente maneraAlmacenamiento Resolución de problemas Problemo Causa AccionEspecificaciones del Generador Información Técnica Sobre el MotorPotencia Nominal Especificaciones del MotorResponsabilidades de la garantía del propietario Piezas garantizadasDuración de la cobertura Mantenimiento Servicio gratuitoSolicitudes y exclusiones de cobertura Cobertura de daños derivadosPeríodo DE Garantía

30235 specifications

The Briggs & Stratton 30235 is a powerful and efficient portable generator designed to provide reliable backup power. Ideal for homeowners and recreational users alike, this model boasts a range of features and technologies that enhance its performance and usability.

One of the standout features of the Briggs & Stratton 30235 is its 306cc engine, which delivers 7,000 starting watts and 5,500 running watts. This robust power output ensures that essential appliances, tools, and devices can be effectively supported during power outages or when on outdoor adventures. The generator is equipped with a durable 4-gallon metal fuel tank, providing up to 13 hours of run time at 50% load, which means users can count on extended operation without frequent refueling.

The generator employs a reliable and user-friendly design, featuring an easy-to-read LED display that provides important information such as power output and operational status. Additionally, it includes an automatic low oil shutdown feature, which protects the engine from damage by shutting down the unit when oil levels are too low. This functionality not only prolongs the life of the generator but also assists users in maintaining optimal performance.

For enhanced portability, the Briggs & Stratton 30235 comes with a built-in handle and never-flat wheels, making it easy to transport and position wherever needed. Its compact footprint allows it to be stored without taking up excessive space, making it an ideal choice for those with limited storage options.

The generator also features multiple outlets, including 120V 20A NEMA 5-20R duplex receptacles and a 120/240V 30A L14-30R lockable receptacle. This versatility allows users to connect a variety of devices and appliances, enhancing its usability for different applications, from home backup to camping trips.

In terms of safety, the Briggs & Stratton 30235 includes circuit protection to prevent overloading, ensuring that connected devices are protected. Moreover, it runs quietly compared to many other generators in its class, making it suitable for use in residential areas without causing a disturbance.

Overall, the Briggs & Stratton 30235 combines power, portability, and practicality, making it a top choice for those in need of reliable backup power or portable energy solutions. With its thoughtful design and advanced features, this generator stands out as a dependable companion for any situation that requires consistent electrical support.
Top Page Image Contents