Compaq 3000 Series manual Testing New Batteries

Page 67

Battery Maintenance 5-11

4.Reinstall the faceplate. Attach the LED display cable to the LED display, aligning the two alignment pins on the smooth side of the connector with the slots at the bottom of the receptacle.

1

Figure15-10. Reattaching the LED display cable

Faceplate attachment slots

5.Replace the four screws holding the faceplate to the chassis, taking the necessary precautions to avoid damaging the LED display cable when repositioning the faceplate.

IMPORTANT: Take the appropriate precautions when installing the new battery pack in order to avoid damaging the LED display cable.

Step 4: Testing New Batteries

After installing the new batteries, press the TEST/ALARM RESET button. See Chapter 3, “Operation,” for information on running a self-test.

IMPORTANT: The UPS will not execute a self-test until the batteries are 90% charged.

If the installation has been successful, the green Battery Charge indicators (LEDs 6 to 8) show that the UPS is charging the batteries. This means that the installation is now complete.

If the installation has not been successful, the Battery Service indicator (LED 10) will turn red. If this occurs, check the battery terminal connections. If the Battery Service indicator is still red, see Chapter 6, “Troubleshooting,” for more information.

Image 67

Contents

3000SeriesUPS Page Contents Iv Compaq 3000 Series UPS Operation and Reference Guide InstallationAppendix a Vi Compaq 3000 Series UPS Operation and Reference Guide Appendix CText Conventions About This GuideSymbols on Equipment Symbols in TextViii Compaq 3000 Series UPS Operation and Reference Guide About This Guide PrecautionsGetting Help Rack StabilityCompaq 3000 Series UPS Operation and Reference Guide Compaq Website Compaq Authorized Reseller Compaq Technical SupportOverview 2Compaq 3000 Series UPS Operation and Reference Guide Compaq 3000 Series UPS ModelsFront Panels Series UPS ModelsOverview Rear Panels4Compaq 3000 Series UPS Operation and Reference Guide Communications port 6Compaq 3000 Series UPS Operation and Reference Guide Standard UPS FeaturesCommunications Port Power Management SoftwareHardware Option Cards Compaq Power Management Software8Compaq 3000 Series UPS Operation and Reference Guide Compaq Scalable UPS Card Compaq Multi-Server UPS CardCompaq SNMP-EN Internal Adapter Remote Emergency Power Off Repo Port10Compaq 3000 Series UPS Operation and Reference Guide Pre-Failure Battery Warranty $25,000 Computer Load Protection GuaranteeWarranties Installation Items not supplied with the UPS kit Installation RequirementsItems supplied with the UPS kit Before Starting the UPS InstallationRack Mounting the UPS Connecting the Remote Emergency Power Off Connecting to the Communications PortRemoving the connector block Starting the UPS Checking the Battery Recharge Date LabelConnecting Devices to the UPS Connecting the UPS to Utility PowerFront panel LED display and controls Powering up the UPSCheck the front panel LED display Completing the InstallationInstallation is Now Complete Placing the UPS in Operate modeOperation Modes of Operation Standby ModeOperate Mode Configure ModeFront Panel Controls Sleep ModeOperation 4Compaq 3000 Series UPS Operation and Reference Guide Front Panel LEDs Standby and Operate Modes Front Panel IndicatorsAC Input LEDs Battery Charge LEDs Site Wiring Fault LEDBattery Service LED Communication LED Load Level LEDsOn LED Overcurrent Protection Overcurrent ProtectionPlacing the UPS in Operate Mode Standby mode controls Returning to Standby ModeInitiating a Self-test 12Compaq 3000 Series UPS Operation and Reference Guide Audio AlarmSilencing an Audio Alarm Audio Alarm ConditionsOperation Configuration Configure mode controls On LED LED On button Placing the UPS in Configure ModeConfiguration Configuration Parameters and their LED IndicatorsExplanation Configuration Parameters/LED IndicatorsConfiguration Parameters/LED Indicators Changing Configuration Parameters Optimizing Battery Life By Matching the Utility Voltage Nominal Configuration Operating Ranges VAC All High Voltage Models Operating Ranges VAC North America and Japanese ModelsBattery Maintenance 2Compaq 3000 Series Operation and Reference Guide Battery Maintenance When to Replace BatteriesCharging Batteries 4Compaq 3000 Series Operation and Reference Guide Pre-Failure Battery WarrantyObtaining New Batteries Replacing BatteriesTo replace batteries with the UPS Off Removing the Battery PackTo replace batteries with the UPS Operate mode hot-swapping Preparing the UPSRemoving the faceplate 6Compaq 3000 Series Operation and Reference GuideRemove two screws to access the battery pack 8Compaq 3000 Series Operation and Reference Guide Disconnecting the battery pack terminal connectionsSliding the battery pack out to reveal the second handle Installing New Batteries10Compaq 3000 Series Operation and Reference Guide Replacing the battery cable retainer bracket Battery cablesTesting New Batteries Disposing of Used Batteries Care and Storage of Batteries12Compaq 3000 Series Operation and Reference Guide Troubleshooting Troubleshooting Guide UPS Start Troubleshooting During StartTroubleshooting Guide After Start Troubleshooting After StartTroubleshooting Troubleshooting Guide After Start Repairing the UPS Federal Communications Commission Notice Regulatory Compliance NoticesClass B Equipment Class a EquipmentCables ModificationsRegulatory Compliance Notices A-3 European Union Notice Canadian Notice Avis CanadienRegulatory Compliance Notices A-5 Japanese Notice Taiwanese NoticeBattery Replacement Notice Electrostatic Discharge Grounding Methods Specifications Table C-2 Input Specifications 3000 Series UPS Models Physical SpecificationsInput Specifications Table C-1 Physical Specifications 3000 Series UPS ModelsTable C-3 Output Specifications 3000 Series UPS Models Output SpecificationsSpecifications C-3 Output Table C-4 Output Specifications 3000 Series UPS ModelsTable C-5 Overcurrent Protection Per Model Battery SpecificationsTable C-6 Battery Specifications 3000 Series UPS Models Specifications C-5Battery Runtime Specifications C-7 Environmental SpecificationsIndex Numbers and SymbolsCompaq 3000 Series UPS Operation and Reference Guide Index Http Index Important Safety Information Important Safety Information x, 2-2,2-3 Compaq 3000 Series UPS Operation and Reference Guide

Related manuals

Manual 24 pages 45.81 Kb