Desa CGCDV42PR, CGCDV42NR installation manual What to do if YOU Smell GAS, Patent Pending

Page 1

DIRECT-VENT FIREPLACE

OWNER’S OPERATION AND INSTALLATION MANUAL

Patent Pending

NATURAL GAS MODELS

(V)VC42N AND CGCDV42NR SERIES

PROPANE/LP GAS MODELS

(V)VC42P AND CGCDV42PR SERIES

WARNING: If the information in this manual is not fol- lowed exactly, a fire or explosion may result causing property damage, personal injury or loss of life.

—Do not store or use gasoline or other flammable vapors and liquids in the vicinity of this or any other appliance.

—WHAT TO DO IF YOU SMELL GAS

•Do not try to light any appliance.

•Do not touch any electrical switch; do not use any phone in your building.

•Immediatelycallyourgassupplierfromaneighbor’s phone. Follow the gas supplier’s instructions.

•If you cannot reach your gas supplier, call the fire department.

—Installation and service must be performed by a quali- fied installer, service agency or the gas supplier.

INSTALLER: Leave this manual with the appliance

CONSUMER: Retain this manual for future reference.

For more information, visit www.desatech.com

Image 1

Contents Patent Pending What to do if YOU Smell GASSafety Information Table of ContentsSafety Information Local Codes Product IdentificationHigh traffic areas Pre-Installation Preparation Product FeaturesLocation and space requirements This fireplace does not require electricity to operateMinimum clearances to combustibles for Clearances42 1067 mm Front 36 914 mm Top of Standoffs VentNoncombustible mantels at any height above Framing and finishingFireplace Balcony with Perpendicular Side Wall Location of Termination CapInstallation Precautions Venting Installation InstructionsInstallation Planning Installing Horizontal Vent Cap Noncombustible Exterior Round Termination Ground Floor InstallationRecommended Applications Corner ground floor installation Corner InstallationHorizontal System Installation Using TWO 90 Elbows Flat Ceiling Installation Installation for vertical terminationConnect a section of pipe and extend up through the hole Twist-lock the vent cap onto the last section of vent pipe Vertical Venting High Altitude InstallationDesa 5/8 Pipe & Vent Kits Number Description Parts list for venting kits and componentsInstalling optional blower accessories Fireplace InstallationModel BK Installation Plug in blower power cordBlower Model BKT Model BKT InstallationBlower Wiring Diagram Installing Gas Piping to Fireplace LocationInstallation Items Needed Propane/LP From Connecting Fireplace to GAS SupplyTest Pressures Equal To or Less Than Psig 3.5 kPa Checking GAS ConnectionsInstalling Remote Receiver Pressure Testing Fireplace Gas ConnectionsRemoving/Replacing Glass Door Replace battery cover onto remote control unitRemoving Louver Panels Removing Glass DoorInstalling Brick liner Models BL42DASA and BL42DHASA Installing lava rock and glowing embersReplace screen/rod assembly by reversing step Cleaning Glass DoorOperating Fireplace For your safety Read before lightingLighting Instructions Close top and bottom louversOptional Hand-Held To Turn OFF GAS To Appliance Manual Lighting ProcedureRemote Operation Thermostat Series Model HRC200 On/Off Series Model HRC100Pilot assembly Operating optional blower accessoryKey Pad Lock Feature Inspecting BurnersBurner Flame Pattern Cleaning MaintenanceGlass Door Logs Pilot and burnersVenting system Observed Problem Possible Cause Remedy TroubleshootingBurner orifice clogged Clean burner see Cleaning Is lit Problem could be caused by Replace pilot assemblyAfter pilot lights, keep gas Long enough Control knob pressedTery power is low When burner is lit HI position when burner isTurning gas control knob to Cold Minute Air in gas line Operate burner until air isStatement above Gas leak. See WarningService Hints Replacement PartsTechnical Service SpecificationsIllustrated Parts Breakdown Parts List 19 18 116236-01G Burner Pan Assembly Accessories Wall mounted thermostat control kit gwmt1 Wall mounted on/off switchGwmS2 Not Shown Keep this Warranty Warranty InformationLimited Warranty DIRECT-VENT Fireplace