Craftsman 919.167242 owner manual Pressure reading

Page 20

PROBLEM

CAUSE

CORRECTION

Pressure reading

It is normal for "some"

If there is an excessive

on the regulated

pressure drop to occur.

amount of pressure drop

pressure gauge

 

when the accessory is used,

drops when an

 

adjust the regulator following

accessory is

 

the instructions in the

used.

 

"Description of Operation"

 

 

paragraph in the "Operation

 

 

Section.

 

 

NOTE: Adjust the regulated

 

 

pressure under flow

 

 

conditions (while accessory

 

 

is being used).

Compressor is

Prolonged excessive use of

Decrease amount of air

not supplying

air.

usage.

enough air to

 

Check the accessory air

operate

Compressor is not large

accessories.

enough for air requirement.

requirement. If it is higher

 

 

than the SCFM or pressure

 

 

supplied by your air

 

 

compressor, you need a

 

 

larger compressor.

 

Hole in hose.

Check and replace if

 

 

required.

 

Check valve restricted.

Remove and clean, or

 

 

replace.

 

Air leaks.

Tighten fittings.

 

 

 

Regulator knob

Damaged regulator.

Replace.

has continuous

 

 

air leak.

 

 

 

 

 

Regulator will

Damaged regulator.

Replace.

not shut off air

 

 

outlet.

 

 

 

 

 

A08598

20- ENG

Image 20
Contents AIR Compressor Table of Contents Important Safety Instructions Specification ChartSafety Guidelines Definitions Spray area. An additional length of hose Explosion May be requiredLocation away from compressor Fire, do not allow the compressor toAttachments & Accessories What Could HappenSafety equipment must be properly Accordance with national and localElectrical codes Electrical Grounding Failure to provideOr attempt maintenance until unit has Result in serious burnsHot for several minutes after operation Do not reach around protective shroudsHazard Accessories AccessoriesGlossary Duty CycleAssembly Contents of CartonTools Required for Assembly Installing Handles Wheels, and Molded Foot BumpersInstallation Location of the Air CompressorGrounding Instructions Plug Grounded Outlets Grounding PinExtension Cords Voltage and Circuit ProtectionOperation Know Your Air CompressorDescription of Operation RegulatorHow to Stop Before Starting Break-in ProcedureDrain Valve Check ValveHow to Start Before Each Start-UpMaintenance To Check Safety ValveCustomer Responsibilities To Drain TankService and Adjustments To Replace or Clean Check ValveOutlet Tube Nut Check Valve Screwdriver Open position nothing is visibleRegulator Arrow StorageTo Replace Regulator Troubleshooting Pressure reading Problem Cause Correction Garantía Total DE UN AÑO DEL Compresor DE Aire ContenidoGarantía Definiciones DE Normas DE Seguridad Modelo Nº 919.167242Resultar en lesiones menores o ModeradasCómo prevenirlo Instrucciones Importantes DE SeguridadGuarde Estas Instrucciones Advertencia Riesgo de Explosión Qué puede occurrir Cómo prevenirloA08598 30- SP Advertencia Riesgo de Quemaduras Qué puede occurrir Advertencia Riesgo de Caída Qué puede occurrirAdvertencia Riesgo de Operación Insegura Qué puede occurrir Glosario AccesoriosCiclo DE Servicio AccesoriosEnsamblado Contenido del embalajeHerramientas requeridas para el ensamblado Instalación de manijas, ruedas y pie moldeado de reboteUbicación del compresor de aire InstalaciónCómo Preparar LA Unidad Cables de extensión eléctrica Protección del voltaje y del circuitoOperación Conozca su compresor de aireDescripción de operaciones Presión de salida TanqueCómo detenerla Cómo utilizar su unidadAntes de poner en marcha Antes de cada puesta en marcha Cómo poner en marchaMantenimiento Responsabilidades del clienteCómo verificar la válvula de seguridad Cómo drenar el tanqueServicio Y Ajustes Para reemplazar o limpiar la válvula reguladoraTubo de salida Tuerca Destornillador En posición abierta nada es visiblePara reemplazar el regulador Regulador FlechaAlmacenaje Guía DE Diagnóstico DE Problemas Problema Causa CorrecciónRiesgo Alguna porque se debilitaráDesciende cuando El motor no funciona Product replacement if your covered product cant be fixed Repair Protection AgreementsGet it fixed, at your home or ours