Porter-Cable C2555 instruction manual Oil, Changing

Page 17

Risk of of Bursting. Water will condense in the air tank. If not drained, water will corrode and weaken the air tank

causing a risk of air tank rupture.

6.After the water has been drained, close the drain valve (clockwise). The air compressor can now be stored.

NOTE: If drain valve is plugged, release all air pressure. The valve can then be removed, cleaned, then reinstalled.

Oil

Risk of Bursting. Drain tank to release air pressure before removing the dipstick or oil drain plug. See “To Drain

Tank” in this section.

Risk of Burns. Compressor head and cylinder sleeve are very hot. Do not touch. Allow compressor to cool prior

to servicing.

Risk from Flying Objects. Make sure air

vent (C) in dipstick is free from debris. If air vent is blocked pressure can build in crankcase causing damage to air compressor and possible personal injury. See Troubleshooting for correction.

Risk of Unsafe Operation. Overfilling

with oil will cause premature compressor failure. Do not overfill.

Checking

	C
	A
	(+)Full	+
B	(-)Add	-
	(-)Add

1.Set the On/Auto/Off lever to “OFF” and unplug unit.

2.Remove dipstick (A) and check oil on dipstick for visual signs of contaminants (water, dirt, etc).

3.Wipe oil from dipstick.

4.Replace dipstick and allow oil to collect on dipstick.

5.Remove dipstick and check oil level on dipstick, + mark indicates full and the - mark indicates add oil. If oil level is below - mark, slowly add oil until it reaches the + (full) mark on the dipstick.

NOTE: Use an oil specifically formulated for use in an air compressor, such as Porter-Cable PAS1 air compressor oil. Oil may be found at the store where the air compressor was purchased.

6.Replace dipstick (A).

Changing

1.Set the On/Auto/Off lever to “OFF” and unplug unit.

2.Remove the dipstick (A).

3.Remove the oil drain plug (B) and drain oil into a suitable container.

4.Replace the oil drain plug (B).

5.Slowly fill crankcase with oil. Crankcase capacity is 8 fluid ounces (236.6 ml). Oil level should be at the + (full) mark on the dipstick.

Risk of Unsafe Operation. Overfilling with oil will cause premature compressor failure. Do not overfill.

6.Replace dipstick (A).

17- ENG

D29795

Image 17

Contents C2555 ModelImportant Safety Instructions Safety Guidelines DefinitionsOr serious injury Minor or moderate injury Death or serious injuryExplosion May be required Spray area. An additional length of hoseLocation away from compressor Fire, do not allow the compressor toWhat Could Happen Attachments & AccessoriesElectricity. Like any other electrically Safety equipment must be properlyRepairs attempted by unqualified Air to all applicable local and federalResult in serious burns Or attempt maintenance until unit hasHot for several minutes after operation Do not reach around protective shroudsFire, Inhalation, Damage to Vehicle Surfaces Duty Cycle SpecificationsGlossary Assembly AccessoriesTo Add Oil To Pump Location of the Air Compressor InstallationVoltage and Circuit Protection Extension CordsKnow Your Air Compressor Description of Operation OperationDipstick How to StopBefore Starting Before Each Start-Up How to StartTo Check Safety Valve MaintenanceCustomer Responsibilities To Drain TankChanging OilMotor Air Filter Inspection and ReplacementTo Replace Regulator Service and AdjustmentsRecommended Handle Alternate Handle Storage StorageTroubleshooting Pressure reading Problem Cause Correction Problem Cause Correction ENG D29795 Responsibility of Original Purchaser initial User Limited WarrantyManual de Muerte o lesiones serias Definiciones DE Normas DE SeguridadModeradas Lesiones serias Causar daños en la propiedadCómo prevenirlo Instrucciones Importantes DE SeguridadQué puede occurrir Cómo prevenirlo Advertencia Riesgo de Explosión31- SP D29795 Advertencia Riesgo de Caída Qué puede occurrir Advertencia Riesgo de Quemaduras Qué puede occurrirAdvertencia Riesgo de Operación Lasegura Qué puede occurrir Ciclo DE Servicio GlosarioEspecificaciones C2555Ensamblado AccesoriosAgregado de aceite a la bomba Ubicación del compresor de aire InstalaciónEnchufe Toma Espiga de conexión a tierraProtección del voltaje y del circuito Cables de extensión eléctricaDescripción de operaciones OperaciónConozca su compresor de aire Antes de poner en marcha Cómo utilizar su unidadCómo detenerla Procedimiento para el asentamientoCómo poner en marcha Antes de cada puesta en marchaCómo verificar la válvula de seguridad MantenimientoCómo drenar el tanque Tanque, creando el riesgo de su ruptura o explosiónVerifique AceiteCambio Filtro de Aire Inspección y reemplazo Para reemplazar el regulador Servicio Y AjustesAlmacenaje Guía DE Diagnóstico DE Problemas Desciende cuando 49- SP D29795 D29795 50- SP Nota Responsabilidad DEL Comprador Original Usuario inicial Garantía LimitadaManuel Consignes DE Sécurité Importantes Mesures DE Sécurité DéfinitionsOu la mort Causer des blessures mineures ou Moyennes Évité, peut causer des dommages à laAvertissement Risque dexplosion ou dincendie Prévention Conserver ces directivesAvertissement Risque de projection dobjets Avertissement Risque déclatementRisque Prévention Avertissement Risque par inhalation Avertissement Risque de choc électriqueAvertissement Risque de chute Avertissement Risque de brûluresAvertissement Risque relié aux pièces mobiles Avertissement Risque dune utilisation dangereuse RisqueNo de modèle C2555 Cycle DE ServiceLexique Assemblage AccessoiresAjout dhuile à la pompe Montage DE Lappareil Emplacement du compresseur dairProtection contre la surtension et protection du circuit RallongesFamiliarisez-vous avec votre compresseur dair UtilisationProcédures de rodage Arrêt de lappareilAvant le démarrage Mise en marche Avant chaque mise en marcheVérification de la soupape de sûreté EntretienResponsabilités du consommateur Vidange du réservoirVidange HuileVérification Moteur Filtre à air Inspection et remplacementEntretien ET Réglages Remplacement du régulateurRangement Rangement Recommandé DES Poignées Rangement AlternatifDépannage Accessoires Exigences en air Le moteur ne Bruit de Remarque D29795 78- FR 79- FR D29795 Responsabilité DE Lacheteur Dorigine utilisateur initial Garantie Limitée