Porter-Cable C2555 instruction manual Troubleshooting

Page 21

TROUBLESHOOTING

Performing repairs may expose voltage sources, moving parts or compressed air sources, moving parts or

compressed air sources. Personal injury may occur. Prior to attempting any repairs, unplug the air compressor and bleed off all air tank air pressure.

	PROBLEM	CAUSE		CORRECTION
	Excessive tank	Pressure switch does not	Set On/Auto/Off lever to the
	pressure -	shut off motor when	"OFF" position, if the outfit
	safety valve	compressor reaches "cut-	does not shut off contact a
	pops off.	out" pressure.	Trained Service Technician.
			Contact a Trained Service
		Pressure switch "cut-out"	Technician.
		too high.

	Air leaks at	Tube fittings are not tight	Tighten fittings where air can
	fittings.	enough.	be heard escaping. Check
			fittings with soapy water
			solution. DO NOT
			OVERTIGHTEN.

	Air leaks at or	Check valve seat damaged.		A defective check valve
	inside check			results in a constant air leak
	valve			at the pressure release valve
				when there is pressure in the
				tank and the compressor is
				shut off. Contact a Trained
				Service Technician to
				replace check valve.

	Air leaks at	Defective pressure switch	Contact a Trained Service
	pressure switch	release valve.	Technician.
	release valve.
	(if equipped)

	Air leaks in air	Defective air tank.	Air tank must be replaced.
	tank or at air		Do not repair the leak.
	tank welds.						Risk of


							Bursting.


			Do not drill into, weld or
			otherwise modify air tank
			or it will weaken. The tank
			can rupture or explode.

	Air leaks	Leaking seal.	Contact a Trained Service
	between head		Technician.
	and valve plate.

21- ENG

D29795

Image 21

Contents C2555 ModelImportant Safety Instructions Safety Guidelines DefinitionsOr serious injury Minor or moderate injury Death or serious injuryExplosion May be required Spray area. An additional length of hoseLocation away from compressor Fire, do not allow the compressor toWhat Could Happen Attachments & AccessoriesElectricity. Like any other electrically Safety equipment must be properlyRepairs attempted by unqualified Air to all applicable local and federalResult in serious burns Or attempt maintenance until unit hasHot for several minutes after operation Do not reach around protective shroudsFire, Inhalation, Damage to Vehicle Surfaces Specifications GlossaryDuty Cycle Assembly AccessoriesTo Add Oil To Pump Location of the Air Compressor InstallationVoltage and Circuit Protection Extension CordsKnow Your Air Compressor Description of Operation OperationHow to Stop Before StartingDipstick Before Each Start-Up How to StartTo Check Safety Valve MaintenanceCustomer Responsibilities To Drain TankChanging OilMotor Air Filter Inspection and ReplacementTo Replace Regulator Service and AdjustmentsRecommended Handle Alternate Handle Storage StorageTroubleshooting Pressure reading Problem Cause Correction Problem Cause Correction ENG D29795 Responsibility of Original Purchaser initial User Limited WarrantyManual de Muerte o lesiones serias Definiciones DE Normas DE SeguridadModeradas Lesiones serias Causar daños en la propiedadCómo prevenirlo Instrucciones Importantes DE SeguridadQué puede occurrir Cómo prevenirlo Advertencia Riesgo de Explosión31- SP D29795 Advertencia Riesgo de Caída Qué puede occurrir Advertencia Riesgo de Quemaduras Qué puede occurrirAdvertencia Riesgo de Operación Lasegura Qué puede occurrir Ciclo DE Servicio GlosarioEspecificaciones C2555Ensamblado AccesoriosAgregado de aceite a la bomba Ubicación del compresor de aire InstalaciónEnchufe Toma Espiga de conexión a tierraProtección del voltaje y del circuito Cables de extensión eléctricaOperación Conozca su compresor de aireDescripción de operaciones Antes de poner en marcha Cómo utilizar su unidadCómo detenerla Procedimiento para el asentamientoCómo poner en marcha Antes de cada puesta en marchaCómo verificar la válvula de seguridad MantenimientoCómo drenar el tanque Tanque, creando el riesgo de su ruptura o explosiónAceite CambioVerifique Filtro de Aire Inspección y reemplazo Para reemplazar el regulador Servicio Y AjustesAlmacenaje Guía DE Diagnóstico DE Problemas Desciende cuando 49- SP D29795 D29795 50- SP Nota Responsabilidad DEL Comprador Original Usuario inicial Garantía LimitadaManuel Consignes DE Sécurité Importantes Mesures DE Sécurité DéfinitionsOu la mort Causer des blessures mineures ou Moyennes Évité, peut causer des dommages à laAvertissement Risque dexplosion ou dincendie Prévention Conserver ces directivesAvertissement Risque déclatement Risque PréventionAvertissement Risque de projection dobjets Avertissement Risque par inhalation Avertissement Risque de choc électriqueAvertissement Risque de brûlures Avertissement Risque relié aux pièces mobilesAvertissement Risque de chute Avertissement Risque dune utilisation dangereuse RisqueCycle DE Service LexiqueNo de modèle C2555 Assemblage AccessoiresAjout dhuile à la pompe Montage DE Lappareil Emplacement du compresseur dairProtection contre la surtension et protection du circuit RallongesFamiliarisez-vous avec votre compresseur dair UtilisationArrêt de lappareil Avant le démarrageProcédures de rodage Mise en marche Avant chaque mise en marcheVérification de la soupape de sûreté EntretienResponsabilités du consommateur Vidange du réservoirHuile VérificationVidange Moteur Filtre à air Inspection et remplacementEntretien ET Réglages Remplacement du régulateurRangement Rangement Recommandé DES Poignées Rangement AlternatifDépannage Accessoires Exigences en air Le moteur ne Bruit de Remarque D29795 78- FR 79- FR D29795 Responsabilité DE Lacheteur Dorigine utilisateur initial Garantie Limitée