Delta A08590 Maintenance, How to Start, Customer Responsibilities, To Check Safety Valve

Page 13

How to Start:

1.Turn the On/Auto/Off lever to "AUTO" and allow tank pressure to build. Motor will stop when tank pressure reaches "cut-out" pressure.

2.Turn regulator knob clockwise to increase pressure and stop when desired pressure is reached. The compressor is ready for use.

NOTE: Always operate the air compressor in well-ventilated areas free of gasoline or other combustible vapors. If the compressor is being used to operate a sprayer DO NOT place near the spray area.

	MAINTENANCE
Customer Responsibilities

	Before each use	Daily or after
	Before each use	each use
		each use
Check Safety Valve	●
Drain Tank		●

To Check Safety Valve

If the safety valve does not work properly, over- pressurization may occur, causing air tank rupture

or an explosion. Before starting compressor, pull the ring on the safety valve to make sure that the safety valve operates freely. If the valve is stuck or does not operate smoothly, it must be replaced with the same type of valve.

To Drain Tank

1.Set the On/Auto/Off lever to "OFF".

2.Pull the regulator knob out and turn counter-clockwise to set the outlet pressure to zero.

3.Remove the air tool or accessory.

4.Pull ring on safety valve allowing air to bleed from the tank until tank pressure is approximately 20 psi. Release safety valve ring.

5.Drain water from air tank by opening drain valve (counter-clockwise) on bottom of tank.Water will condense in the air tank.

If not drained, water will corrode and weaken the air tank causing a risk of air tank rupture.

6.After the water has been drained, close the drain valve (clockwise). The air compressor can now be stored.

NOTE: If drain valve is plugged, release all air pressure. The valve can then be removed, cleaned, then reinstalled.

13- ENG

A08590

Image 13

Contents Oil-Free Air Compressor Important Safety Instructions Safety Guidelines DefinitionsDeath or serious injury Or moderate injury Death or serious injuryAlways remain in attendance with What Could HappenAttachments & Accessories Repairs attempted by unqualified Electricity. Like any other electricallyTo human consumption Your specific applicationHazard Warning Risk from Moving Parts Result in serious burns How To Prevent ItKeep children away from the air compressor at all times Transporting CompressorEquip area of operation with a fire extinguisher Accessories SpecificationsGlossary Duty CycleLocation of the Air Compressor InstallationVolt U.S.A. Plug Grounding PinVoltage and Circuit Protection Extension CordsKnow Your Air Compressor Description of Operation OperationBefore Starting How to StopBefore Each Start-Up Check ValveHow to Start MaintenanceTo Check Safety Valve Customer ResponsibilitiesTo Replace or Clean Check Valve Service and AdjustmentsOutlet Tube Nut Check Valve To Replace Regulator Troubleshooting Being used Problem Cause Correction ENG A08590 Limited Warranty Compresor de Aire Sin Aceite Lesiones serias Resultar en lesiones menores o Moderadas Definiciones DE Normas DE SeguridadLesiones serias Cómo prevenirlo Instrucciones Importantes DE SeguridadQué puede occurrir Cómo prevenirlo Advertencia Riesgo de Explosión29- SP A08590 Advertencia Riesgo de Partes Móviles Qué puede occurrir Advertencia Riesgo de Quemaduras Qué puede occurrirAdvertencia Riesgo de Caída Qué puede occurrir Advertencia Riesgo de Operación Lasegura Qué puede occurrir Ciclo DE Servicio GlosarioEspecificaciones AccesoriosEnchufe de 120 V, EE.UU InstalaciónUso local Protección del voltaje y del circuito Cables de extensión eléctricaConozca su compresor de aire OperaciónDescripción de operaciones Antes de poner en marcha Cómo utilizar su unidadCómo detenerla Procedimiento para el asentamientoCómo poner en marcha MantenimientoResponsabilidades del cliente Cómo verificar la válvula de seguridadPara reemplazar o limpiar la válvula reguladora Servicio Y AjustesTuerca Válvula reguladora Para reemplazar el regulador AlmacenajeOriginando un riesgo de ruptura de sus paredes Guía DE Duagnóstico DE Problemas Se utiliza un Automático. No use un fusible o Notas AÑO Garantía limitada sobre todos los servicios Garantía LimitadaCompresseur dair sans huile Consignes DE Sécurité Importantes Mesures DE Sécurité DéfinitionsOu la mort Causer des blessures mineures ou Moyennes Évité, peut causer des dommages à laAvertissement Risque dexplosion ou dincendie Prévention Conserver ces directivesRisque Prévention Avertissement Risque déclatementAvertissement Risque de projection dobjets Avertissement Risque par inhalation Avertissement Risque de choc électriqueAvertissement Risque relié aux pièces mobiles Avertissement Risque de brûluresAvertissement Risque de chute Prévention Transport du compresseur Avertissement Risque de dommages à la propriété pendant leAvertissement Risque dune utilisation dangereuse Accessoires Cycle DE ServiceLexique SpécificationsMontage DE Lappareil Emplacement du compresseur dairProtection contre la surtension et protection du circuit RallongesFamiliarisez-vous avec votre compresseur dair UtilisationDescription du fonctionnement Arrêt de lappareil Utilisation de lappareilAvant le démarrage Avant chaque mise en marcheMise en marche EntretienResponsabilités du client Vérification de la soupape de sûretéEntertien ET Réglages Remplacement ou nettoyage de la soupape de retenueRangement Remplacement du régulateurSerrer DépannagePeut éclater ou exploser Est utilisé, ajustez le régulateur Fusible sauté ou coupe-circuit Remarque Garantie Limitée AN Garantie limitée sur tous les accessoires