Delta A08590 instruction manual To Replace Regulator

Page 15

To Replace Regulator

1.Release all air pressure from air tank. See "To Drain Tank" in the Maintenance section.

2.Unplug outfit.

3.Using an adjustable wrench remove the gauges and hose from the regulator.

4.Remove the regulator.

5.Apply pipe sealant tape to the nipple on the standpipe.

6.Assemble the regulator and orient as shown.

NOTE: Arrow indicates flow of air. Make sure it is pointing in the direction of air flow.

7.Reapply pipe sealant to gauges and hose.

8.Reassemble gauges and hose. Orient gauges to read correctly. Tighten hose with wrench.

Regulator

Arrow

STORAGE Before you store the air compressor, make sure you do the following:

1.Review the "Maintenance" section on the preceding pages and perform scheduled maintenance as necessary.

2.Set the On/Auto/Off lever to "OFF".

3.Turn the regulator counterclockwise and set the outlet pressure to zero.

4.Remove the air tool or accessory.

5.Pull ring on safety valve allowing air to bleed from the tank until tank pressure is approximately 20 psi. Release safety valve ring.

6.Drain water from air tank by opening drain valve on bottom of tank.

Water will condense in the air tank. If not drained, water will corrode and weaken the air tank causing a risk of air tank rupture.

7.After the water has been drained, close the drain or drain valve.

NOTE: If drain valve is plugged, release all air pressure. The valve can then be removed, cleaned, then reinstalled.

8.Protect the electrical cord and air hose from damage (such as being stepped on or run over). Wind them loosely around the compressor handle. (If so equipped)

9.Store the air compressor in a clean and dry location.

15- ENG

A08590

Image 15

Contents Oil-Free Air Compressor Death or serious injury Safety Guidelines DefinitionsImportant Safety Instructions Death or serious injury Or moderate injuryAlways remain in attendance with What Could HappenAttachments & Accessories Your specific application Electricity. Like any other electricallyRepairs attempted by unqualified To human consumptionHazard Warning Risk from Moving Parts Result in serious burns How To Prevent ItTransporting Compressor Keep children away from the air compressor at all timesEquip area of operation with a fire extinguisher Duty Cycle SpecificationsAccessories GlossaryGrounding Pin InstallationLocation of the Air Compressor Volt U.S.A. PlugVoltage and Circuit Protection Extension CordsKnow Your Air Compressor Description of Operation OperationCheck Valve How to StopBefore Starting Before Each Start-UpCustomer Responsibilities MaintenanceHow to Start To Check Safety ValveService and Adjustments To Replace or Clean Check ValveOutlet Tube Nut Check Valve To Replace Regulator Troubleshooting Being used Problem Cause Correction ENG A08590 Limited Warranty Compresor de Aire Sin Aceite Definiciones DE Normas DE Seguridad Lesiones serias Resultar en lesiones menores o ModeradasLesiones serias Cómo prevenirlo Instrucciones Importantes DE SeguridadQué puede occurrir Cómo prevenirlo Advertencia Riesgo de Explosión29- SP A08590 Advertencia Riesgo de Quemaduras Qué puede occurrir Advertencia Riesgo de Partes Móviles Qué puede occurrirAdvertencia Riesgo de Caída Qué puede occurrir Advertencia Riesgo de Operación Lasegura Qué puede occurrir Accesorios GlosarioCiclo DE Servicio EspecificacionesInstalación Enchufe de 120 V, EE.UUUso local Protección del voltaje y del circuito Cables de extensión eléctricaOperación Conozca su compresor de aireDescripción de operaciones Procedimiento para el asentamiento Cómo utilizar su unidadAntes de poner en marcha Cómo detenerlaCómo verificar la válvula de seguridad MantenimientoCómo poner en marcha Responsabilidades del clienteServicio Y Ajustes Para reemplazar o limpiar la válvula reguladoraTuerca Válvula reguladora Almacenaje Para reemplazar el reguladorOriginando un riesgo de ruptura de sus paredes Guía DE Duagnóstico DE Problemas Se utiliza un Automático. No use un fusible o Notas AÑO Garantía limitada sobre todos los servicios Garantía LimitadaCompresseur dair sans huile Évité, peut causer des dommages à la Mesures DE Sécurité DéfinitionsConsignes DE Sécurité Importantes Ou la mort Causer des blessures mineures ou MoyennesAvertissement Risque dexplosion ou dincendie Prévention Conserver ces directivesAvertissement Risque déclatement Risque PréventionAvertissement Risque de projection dobjets Avertissement Risque par inhalation Avertissement Risque de choc électriqueAvertissement Risque de brûlures Avertissement Risque relié aux pièces mobilesAvertissement Risque de chute Prévention Avertissement Risque de dommages à la propriété pendant le Transport du compresseurAvertissement Risque dune utilisation dangereuse Spécifications Cycle DE ServiceAccessoires LexiqueMontage DE Lappareil Emplacement du compresseur dairProtection contre la surtension et protection du circuit RallongesUtilisation Familiarisez-vous avec votre compresseur dairDescription du fonctionnement Avant chaque mise en marche Utilisation de lappareilArrêt de lappareil Avant le démarrageVérification de la soupape de sûreté EntretienMise en marche Responsabilités du clientEntertien ET Réglages Remplacement ou nettoyage de la soupape de retenueRangement Remplacement du régulateurDépannage SerrerPeut éclater ou exploser Est utilisé, ajustez le régulateur Fusible sauté ou coupe-circuit Remarque Garantie Limitée AN Garantie limitée sur tous les accessoires