Design Dynamics DVF-36S-N installation manual Natural, Propane/LP Gas Models Gas Models

Page 1

Direct vent FIREPLACE

OWNER’S OPERATION AND INSTALLATION MANUAL

NATURAL	Propane/LP
Gas Models Gas Models
DVF-36S-N	DVF-36S-P	Stacked Brick/Standard Glass
dvf-36h-n	dvf-36h-p	Herringbone Brick/Standard Glass
dvf-36sc-n	dvf-36sc-P	Stacked Brick/Cool Touch Glass
dvf-36hc-N	dvf-36hc-P	Herringbone Brick/Cool Touch Glass

WARNING: If the information in this manual is not fol- lowed exactly, a fire or explosion may result causing property damage, personal injury or loss of life.

—Do not store or use gasoline or other flammable vapors and liquids in the vicinity of this or any other appliance.

—WHAT TO DO IF YOU SMELL GAS

•Do not try to light any appliance.

•Do not touch any electrical switch; do not use any phone in your building.

•Immediately call your gas supplier from a neighbor’s phone. Follow the gas supplier’s instructions.

•If you cannot reach your gas supplier, call the fire department.

—Installation and service must be performed by a quali- fied installer, service agency or the gas supplier.

INSTALLER: Leave this manual with the appliance

CONSUMER: Retain this manual for future reference.

For more information, visit www.desatech.com

Image 1

Contents Propane/LP Gas Models Gas Models NaturalStacked Brick/Standard Glass Safety Information Table of ContentsThis fireplace Natural and Propane/LP Gas NaturalProduct Identification Product FeaturesLocal Codes Installation PreinstallationLocation and space requirements Proper clearances must be maintainedFraming and finishing ClearancesFor specific venting ClearancesBalcony with Perpendicular Side Wall Location of Termination CapInstallation Precautions Venting InstallationTwist-Lock Procedure The female Installation PlanningSee , Apply Mastic to All Four Sides Vent Cap Wood ScrewTo All Four Sides Horizontal High Wind Square Termination Elbow Wall FirestopMax max max Flat Ceiling Installation Vertical Termination InstallationHigh Altitude Installation Outside Air Flex InstallationVertical Venting = 40 maxParts list for venting kits and components Fireplace InstallationInstalling Gas Piping to Fireplace Location Check GAS TypeGas Connection Checking GAS Connections Connecting Fireplace to GAS SupplyPsig 3.5 kPa will damage fireplace gas regulator Test Pressures Equal To or Less Than 1/2 Psig 3.5 kPaInstalling Middle Door DVF-36SC/HC Models Only Pressure Testing Fireplace Gas ConnectionsInstalling Outer Door DVF-36SC/HC Models Only FireplaceSpring Loaded Pin Pin Located on Middle DoorHook Located See , Follow these instructions in reverse to reinstallOuter Door Hinge On Inner Door Middle Door Remove screen and rod see ,Side Bricks Side Trim Screen Rod Left Lava Rock, Ember Flakes Scrap Log InstallationBottom Brick Middle Bottom Brick Right Bottom BrickRemote control Installation Model WRC Wall Switch InstallationFor your safety Read before lighting Wiring DiagramOperation Lighting InstructionsInspecting Burners Pilot AssemblyTo Turn OFF GAS To Appliance Remote OperationGlass Doors Cleaning MaintenanceSpecifications Technical ServiceReplacement Parts Service HintsObserved Problem Possible Cause Remedy TroubleshootingPilot will not stay lit 21 and/or check ground wire to ignition moduleTo ignition module and/or Poor ground to ignitionTions, ConfigurationGlass soots Debris around burner air Illustrated Parts Breakdown Not a field replaceable part Parts ListIllustrated parts breakdown Bottom Pan Weldment Illustrated parts breakdown 120168-01 Refractory Trim, RH 120168-02 Refractory Trim, LH 120441-01A 120441-01A Keep this Warranty Warranty InformationLimited Warranty Direct vent Fireplace