Vermont Casting manual Stardance Direct Vent/Natural Vent Gas Heater SDV30

Page 37

Stardance Direct Vent/Natural Vent Gas Heater

Stardance Direct Vent/Natural Vent Gas Heater (SDV30)

Models 3900-3916, 3940-3956 (continued)

Ref.	Description	SDV30
2.	Gasket Cement	1206122
3.	Manifold Assembly	20003739
4.	Lava Rocks Burner	57897
5.	Gasket, Glass - Med. Knit - RDV40	1203702
6.	Glass, DV25	1601691
7.	Glass Frame Assembly - SDV30	30000127
8a.	Valve RN Honeywell VS8420E 2038 (Serial #’s up to 8738)*	10001782
8b.	Valve RP Honeywell VS8420E 2020 (Serial #’s up to 8738)**	10001759
9a.	Valve Gas Honeywell Convertible RFN RV8310E	20003719
9b.	Valve Gas Honeywell Convertible RFP RV8310E	20003720
10a.	Pilot Assembly 3Way N/DV RN 0.199.706	10002264
	Pilot Assembly 3Way N/DV RP 0.199.703	10002265
10b.	Pilot, PSE - NA175	20001115
	Pilot, PSE - LP175	20001116
10c.	Pilot Assembly 3Way DV/RFN CS3003A2009	20002266
	Pilot Assembly 3Way DV/RFP CS3003A2017	20002268
11.	Thermocouple 24”	53373
		7531137
12.	Electrode Ignitor w/Cable SIT24	10001297
13.	Pilot Top Convertible	10002266
14.	Thermopile 18” RS	51827
		7533113
15.	Nut Electrode SIT #0.974.144	57886
16.	Tubing Pilot w/Fittings 1/8 x 24”	10001296
17.	Thermopile - PSE for RF Pilots	20002400
18.	Burner Housing Assembly NG/LP	20002214
19.	Switch ON/OFF - RN/RP Models	30000874
20.	Grate, Burner - JDV	20002167
21.	Wiring Harness - FSDV32 RN/JDV	10002582
22.	Right Log Bracket	20005259
23.	Left Log Bracket	20005258
24.	Door, Control - FS/HM	1301087
25a.	Oriﬁce Hood #69 - Front - LP	30000513
25b.	Oriﬁce Hood #54 - Front - NG	20000130
25c.	Oriﬁce Hood #54 - Rear - LP	20000130
25d.	Oriﬁce Hood #44 - Rear - NG	30000334
26.	Top, Stardance DV	Refer to Enamel Parts Chart Page 38
27.	Nut, Hex Jam 3/8 -16 TOPLK-Z	1203290
28.	Pawl Assy, Ash Door - ENC	5004025
29.	Front Steel Handle/Shaft - NI/VER	30002717
30.	Handle Pkg, Ceramic w/Screw	0004345
31.	Gasket, Base Pan - JDV	20002282
32.	Gasket, Base Pan Inner	20002566
33.	Front, Stardance OP Dr	Refer to Enamel Parts Chart Page 38

*When converting to SIT valve, must order RP275 **When converting to SIT valve, must order RP269

20007065

37

Image 37

Contents What to do if YOU Smell GAS Stardance Direct Vent/Natural Vent Gas HeaterTable of Contents General Information Stardance Direct Vent / Natural Vent Dimensions Clearance Requirements Installation RequirementsMinimum Clearances to Combustible MaterialsWall and Ceiling Clearances Wall Centerline from FloorHearth Requirements Gas Inlet and Manifold Pressures Gas SpeciﬁcationsHigh Elevations Horizontal Termination Direct Vent onlyVent Termination Clearances Vertical Termination Direct Vent onlyDirect Vent Only Location of Vent Termination Vent Termination ClearancesGeneral Venting Information Termination Location Canadian Installations1 US Installations2Termination Clearances Venting Requirements Natural Vent OnlyApproved Vent System Components Venting Requirements and OptionsSimpson DuraVent Components Minimum Horizontal Vent KitRemove rear skirt insert Install the Optional FanVenting System Assemlby Direct Vent General Information Install the Vent Adapter PipeSimpson Dura-Vent install inner adapter pipe Side Wall Termination AssemblyDetermine the vertical pipe length Vent Termination Below Grade Vertical Through the Roof Vent AssemblyInstall ﬁrestops and attic insulation shield Venting System Assembly Natural Vent General InformationInstall the Log Set Install the Vent PipeConnect the Gas Supply Line Aged LogsAir Shutter Adjustment Instructions Air Shutter AdjustmentBurner Information Install ON/OFF Switch Complete the AssemblyThermostat Wire / Gauge Install the Front PlateThis completes assembly of the Stardance stove Thermostat Connection optionalFlame Characteristics Your First Fire Flame & Temperature AdjustmentOperation Pilot and Burner InspectionTo Turn Off Gas To Heater Lighting and Operating InstructionsSymptom Possible Causes Corrective Action Troubleshooting / Honeywell #8420 Gas Control SystemTransmitter Operation Off Mode Shut Off ProcedureOn Manual Mode Delay Timer ModeFan Override During Auto Mode Auto ModeChange Between F/C Temperature Units Disable Thermostat FunctionLocal Path Auto Path Conversion Procedure Conversion PrecautionsFuel Conversion Instructions Models 3900, 3910 R Models Only Honeywell ValvePilot Oriﬁce Conversion Pilot typeModels 3940, 3950 RF Models Only Injector Oriﬁce Size MatrixAll Models 000-5011Logset and Burner Cleaning and Inspection MaintenanceCleaning the Glass Glass ReplacementStove Disassembly Gasket ReplacementInspect the Vent System Annually Check the Gas Flame RegularlyBLK Wiring DiagramsSDV30 DescriptionStardance Direct Vent/Natural Vent Gas Heater SDV30 Fuel Conversion Kits Optional Accessories Stardance Direct Vent/Natural Vent Gas Heater Stardance Direct Vent/Natural Vent Gas Heater Product Covered by this Warranty Limited Lifetime WarrantyProduit Couvert PAR LA Présente Garantie SI UN Service Sous Garantie EST REQUIS…Model EnerGuide Ratings Fireplace Efﬁciency % Efﬁciency Ratings