Regency U32S-NG5 Installation, Installer Notice, the wrench by the short side, Pilot Cap

Page 12
Pilot Cap

INSTALLATION

15) Insert a 5/32” or 4mm Allen wrench into the hexagonal key-way of the screw (Fig. 2), rotate it counter-clockwise until it is free and extract it.

Pilot Cap

9)Pull off the pilot cap to expose the pilot orifice.

WARNING!

Do not overtighten the screw. Recommended to grip

the wrench by the short side.

19)Verify that if the conversion is from NG to LPG, the screw must be re- assembled with the red o-ring visible (Fig. 5).

Red o-ring visible

Fig.5

LPG Configuration

Fig.2

20)Re-assemble the black protection cap (Fig. 6).

10)Unscrew the pilot orifice with the supplied allen key and replace it with the LP pilot orifice and re-install the pilot cap and the pilot shield.

11)Re-install base cover.

12)Re-install the burner.

NOTE: Before re-installing the burner, ensure the LP areation setting is set at 1/2" min. when using glass crystals and 1/8" min. when using ceramic stones.

13)Turn control knob to the “OFF” position.

14)Remove the black protection cap by hand from the high-low knob (Fig.1).

Fig.1

16)Check that the screw is clean and if necessary remove dirt.

17)Flip the screw (Fig. 3).

Fig.3

18)Using the Allen wrench as shown in Fig.4, rotate the screw clockwise until snug, do not overtighten.

Fig.4

Fig.6

WARNING!

Also check that the pilot and
main burner injectors
are appropriate for the gas type.

21)See DC Sparker installation in the instruction manual.

22)Attach the label "This unit has been converted to LPG" near or on top of the serial # decal.

23)Replace yellow "NG" label with red "LPG" label.

24)Check for gas leaks.

25)Check inlet and outlet pressures.

26)Reverse Step 2.

27)Check operation of flame control.

Installer Notice:

These instructions must be left with the appliance.

12

U32S-5 FPI Direct Vent Gas Insert

Image 12
Contents Installation Manual U32 Sunrise Gas InsertOwners 918-788TO THE NEW OWNER TABLE OF CONTENTS SAFETY LABELMAINTENANCE PARTS LISTSAFETY LABEL REQUIREMENTS MA Code - CO Detectorfor the State of Massachusetts only 5.08 Modifications to NFPA-54,ChapterUNIT DIMENSIONS U32S-5FPI Direct Vent Gas InsertINSTALLATION FOR YOUR SAFETYSPECIFICATIONS GAS PRESSURE TESTINGINSTALLATION INSTALLATION CHECKLISTMINIMUM FIREPLACE DIMENSIONS MANUFACTURED MOBILE HOME ADDITIONAL REQUIREMENTSINSTALLATION GAS CONNECTIONVENTING COMBUSTIBLE MANTELINSTALLATION FLUE LINER INSTALLATIONGAS PIPE PRESSURE TESTING GAS INSERT AERATION SYSTEMINSTALLATION U32S-5using SIT 820 NOVA Gas ValveCONVERSION KIT # 434-969FROM NG TO LP IF IN DOUBT DO NOT DO THIS CONVERSIONINSTALLATION Installer NoticeDo not overtighten the screw. Recommended to grip the wrench by the short sideINSTALLATION Installation of the DC SparkerIgnitor Wire Piezo Ignitor Ground wire from kitINSTALLATION OPTIONAL REMOTE CONTROLto the 120V wires Thermostat Wire Table remote control the 120V wiresINSTALLATION WIRING DIAGRAMSCAUTION Label all wires prior to disconnection when servicingINSTALLATION INSTALLATION INSTALLATION ON BURNERGLASS CRYSTAL OR OPTIONAL CERAMIC STONES Minimum Air shutter OpeningINSTALLATION Diagram Diagram 1a Diagram 1b DiagramSTANDARD FLUSH DOOR INSTALLATION FACEPLATE AND DOOR FRAME INSTALLATIONKit# 425-914Contents List Door FrameINSTALLATION Completed Faceplate & Door Frame Installation8Lower the door frame gently into place 10Slide unit into final positionINSTALLATION OPTIONAL HEARTH TRIM INSTALLATION2 Hearth Trim Installation 4 Hearth Trim InstallationOPERATING INSTRUCTIONS LIGHTING PROCEDURESHUTDOWN PROCEDURE OPERATING INSTRUCTIONSMAINTENANCE INSTRUCTIONS OPERATING INSTRUCTIONSCOPY OF LIGHTING INSTRUCTION PLATE DO NOT REMOVE THIS INSTRUCTION PLATEMAINTENANCE GENERAL VENT MAINTENANCEDOOR GLASS GLASS GASKETMAINTENANCE FAN MAINTENANCEFAN REMOVAL BurnerMAINTENANCE Fan access platePilot assembly wires Base CoverMAINTENANCE REPLACING THE FANMAINTENANCE VALVE ASSEMBLY REPLACEMENTON/OFF Wires BurnerMAINTENANCE 11Slightly lift out valve tray12 Disconnect the inlet gas line U32S-5FPI Direct Vent Gas InsertPARTS LIST MAIN ASSEMBLYDescription PARTS LIST BURNER ASSEMBLYDescription 4 10 11 9 13PARTS LIST 1425-512Door Bottom Assembly 2425-513Frame InsideFACEPLATE AND DOORFRAME 3425-514Faceplate Outside 4425-942Hearth TrimU32S-5FPI Direct Vent Gas Insert U32S-5FPI Direct Vent Gas Insert WARRANTY The Warranty Limited LifetimeConditions ExclusionsSee the inside back cover for details