Jackson Tempstar GP technical manual Table of Contents

Page 2

TABLE OF CONTENTS

GENERAL	PAGE
Specifications	1
INSTALLATION
Unpacking	2
Plumbing Connections	2
Electrical Connections	2
Gas Connection	3
OPERATING INSTRUCTIONS
Preparation	4
Power Up	4
Initial Fill	4
Preparing the Dishes	4
Daily Machine Preparation	4
Washing a Rack of Ware	4
Shut Down and Cleaning	4
OVERVIEW OF OPERATION	5
THERMOSTAT ADJUSTMENT PROCEDURE	7
AUTO-CALIBRATION PROCEDURE	8
ELECTRONICS CONTROL BOARD (ECB)	9
TESTING THERMISTORS	10
CONTROL BOARD LED LIGHT INDICATIONS	11
TROUBLESHOOTING	12
DIMENSIONS	19
TABLE DIMENSIONS	20
PHOTOGRAPHS
Main Assembly	21
Control Box Assembly-Front View	22
Control Box Assembly-Top View	23
Hood Assembly	25
Cantilever Arm Assembly	26
Tub Assembly	27
Back of Tub, & Drain Assembly	28
Lower Assembly (Right Side)	29
Incoming Plumbing Assembly	30
Gas Pack Assembly	32
Upper Wash, & Rinse Arm Assembly	33
Lower Wash, & Rinse Arm Assembly	34
Steam Coil Assembly	35
Rinse Tank Assembly	37
Electronic Control Drawer Components	38
SCHEMATICS
110/120 Volt Schematic	39
208/240 Volt Schematic	40

i

Image 2

Contents Technical Manual Table of Contents Specifications of the Tempstar GP Installation Instructions GAS Connection Operation Instructions Overview of Operation Overview of Operation Thermostat Adjustment Procedure AUTO-CALIBRATION Procedure Auto CalibrationTesting and Setting the Set Point Temperature Electronics Control Board ECBTesting the Thermistors To test the temperature at the T-in ThermistorControl Board LED Light Indications Green LED is offTroubleshooting Section Symptom Possible Cause ActionTroubleshooting Section Leaks do not USE Flame Low rinse temperature/low wash Low inlet water temperature Polarity will Damage the Circuit Boards DSICombination cutoff valve and the modulating Check ignition wire. Check that lights above Dimensions Table Dimensions Main Assembly Shown Not ShownControl BOX Assembly Front View QTY Description MFG noControl BOX Assembly TOP View Control BOX ASSEMBLY-TOP View Hood Assembly Cantilever ARM Assembly TUB Assembly Back of TUB, & Drain Assembly Lower Assembly Right Side Incoming Plumbing Assembly Incoming Plumbing Parts Lists GAS Pack Assembly Upper WASH, & Rinse ARM Assembly Lower WASH, & Rinse ARM Assembly Steam Coil Assembly Steam Coil Assembly Parts Lists Rinse Tank Assembly Electronic Control Drawer Components RED Green LEDElectrical Diagram 208/240 Volt 60 Hertz 1 Phase