Jackson Tempstar GP technical manual Upper WASH, & Rinse ARM Assembly

Page 35

UPPER WASH, & RINSE ARM ASSEMBLY

01

02

03

04

05

06

07

08

09

10

11

12


	ITEM	QTY	DESCRIPTION	MFG NO.

	01	2	Wash Arm End Plug	5700-011-35-92
	02	1	Rinse Manifold Assembly	5700-021-47-61
	03	1	Wash Manifold Tube	5700-131-15-07
	04	1	Wash Arm	5700-021-35-93
	05	2	Nut, 3/8-16 Hex	5310-276-01-00
	06	2	Bolt, 3/8-16 X 1-1/4" Long Hex	5305-276-10-00
	07	1	Upper Wash Casting	5700-031-34-82
	08	1	Rinse Arm	5700-031-50-63
	09	8	Locknut, 1/4"- 20 s/s Hex w/Nylon Insert	5310-374-01-00
	10	2	Rinse Arm End Plug	4730-609-04-00
	11	1	Hood Assembly	5700-041-90-56
	12	2	Bracket, Door Connecting	5700-021-33-39

33

Image 35

Contents Technical Manual Table of Contents Specifications of the Tempstar GP Installation Instructions GAS Connection Operation Instructions Overview of Operation Overview of Operation Thermostat Adjustment Procedure Auto Calibration AUTO-CALIBRATION ProcedureElectronics Control Board ECB Testing and Setting the Set Point TemperatureTo test the temperature at the T-in Thermistor Testing the ThermistorsGreen LED is off Control Board LED Light IndicationsSymptom Possible Cause Action Troubleshooting SectionTroubleshooting Section Leaks do not USE Flame Low rinse temperature/low wash Low inlet water temperature DSI Polarity will Damage the Circuit BoardsCombination cutoff valve and the modulating Check ignition wire. Check that lights above Dimensions Table Dimensions Shown Not Shown Main AssemblyQTY Description MFG no Control BOX Assembly Front ViewControl BOX Assembly TOP View Control BOX ASSEMBLY-TOP View Hood Assembly Cantilever ARM Assembly TUB Assembly Back of TUB, & Drain Assembly Lower Assembly Right Side Incoming Plumbing Assembly Incoming Plumbing Parts Lists GAS Pack Assembly Upper WASH, & Rinse ARM Assembly Lower WASH, & Rinse ARM Assembly Steam Coil Assembly Steam Coil Assembly Parts Lists Rinse Tank Assembly RED Green LED Electronic Control Drawer ComponentsElectrical Diagram 208/240 Volt 60 Hertz 1 Phase