Jackson Tempstar GP technical manual Back of TUB, & Drain Assembly

Page 30

BACK OF TUB, & DRAIN ASSEMBLY

14

01

13

02

12

11

03

10

04

05

09

06

				07			08



	ITEM	QTY	DESCRIPTION					MFG NO.

	01	1	Tub Weldment			5700-002-18-77
	02	1	Vent Flue Assembly			5700-002-19-45
	03	1	Wash Pump & Motor Assembly 115-230/60/1			6105-121-99-78
	04	1	Frame Weldment			5700-002-18-78
	05	1	Plumbing, Drain Assembly			5700-002-21-29
	06	1	Bracket, Drain Support			5700-002-20-58
	07	1	Hose, 3/4" Recirculating Pump Suction			5700-002-17-79
	08	2	Elbow, 90 Deg 1/2" Street Brass			4730-206-08-00
	09	2	Bolt, Cantilever Hanger Eye 3/8"-16			5306-956-05-00
	10	2	Plug, Bulk Head			4730-609-05-00
	11	1	Hose, 1/2" Recirculating Pump Discharge			5700-002-17-71
	12	2	Spring			5340-109-02-00
	13	2	Rod, Spring			5700-001-28-18
	14	1	Hose, 1/2" Heat Exchanger Inlet Assembly (not shown)			5700-002-17-73

28

Image 30

Contents Technical Manual Table of Contents Specifications of the Tempstar GP Installation Instructions GAS Connection Operation Instructions Overview of Operation Overview of Operation Thermostat Adjustment Procedure AUTO-CALIBRATION Procedure Auto CalibrationTesting and Setting the Set Point Temperature Electronics Control Board ECBTesting the Thermistors To test the temperature at the T-in ThermistorControl Board LED Light Indications Green LED is offTroubleshooting Section Symptom Possible Cause ActionTroubleshooting Section Leaks do not USE Flame Low rinse temperature/low wash Low inlet water temperature Polarity will Damage the Circuit Boards DSICombination cutoff valve and the modulating Check ignition wire. Check that lights above Dimensions Table Dimensions Main Assembly Shown Not ShownControl BOX Assembly Front View QTY Description MFG noControl BOX Assembly TOP View Control BOX ASSEMBLY-TOP View Hood Assembly Cantilever ARM Assembly TUB Assembly Back of TUB, & Drain Assembly Lower Assembly Right Side Incoming Plumbing Assembly Incoming Plumbing Parts Lists GAS Pack Assembly Upper WASH, & Rinse ARM Assembly Lower WASH, & Rinse ARM Assembly Steam Coil Assembly Steam Coil Assembly Parts Lists Rinse Tank Assembly Electronic Control Drawer Components RED Green LEDElectrical Diagram 208/240 Volt 60 Hertz 1 Phase