Jackson Tempstar GP technical manual Control BOX Assembly Front View, QTY Description MFG no

Page 24

CONTROL BOX ASSEMBLY - FRONT VIEW











			01					02	03			04			05			06					07				08		09		10	11			12

	ITEM	QTY							DESCRIPTION																								MFG NO.

	01	1	Control Box Cover Decal																													9905-021-91-15
	02	1	Rinse Thermometer, 48" Lead																													6685-111-68-48
	03	1	Power Light (Red)																													5945-504-07-18
	04	1	Screw, 10-32 X 3/8" Phillips Truss Head																													5305-173-12-00
	05	1	Delime ( Manual Wash) Switch																													5930-301-21-18
	06	1	On / Off Power Switch																													5930-011-49-55
	07	1	Delime/Normal Decal																													9905-011-34-96
	08a	1	Timer, 220v/60, 8 cam																													5945-021-94-11
	08b	1	Timer, 110v/60, 8 cam																													5945-002-01-73
	09	1	Cycle Light (Green)																													5945-504-08-18
	10	1	Timer Mounting Bracket																													5700-021-34-54
	11	8	Micro Switch																													5945-111-68-49
	12	1	Wash Thermometer, 96" Lead																													5700-111-68-49

22

Image 24

Contents Technical Manual Table of Contents Specifications of the Tempstar GP Installation Instructions GAS Connection Operation Instructions Overview of Operation Overview of Operation Thermostat Adjustment Procedure AUTO-CALIBRATION Procedure Auto CalibrationTesting and Setting the Set Point Temperature Electronics Control Board ECBTesting the Thermistors To test the temperature at the T-in ThermistorControl Board LED Light Indications Green LED is offTroubleshooting Section Symptom Possible Cause ActionTroubleshooting Section Leaks do not USE Flame Low rinse temperature/low wash Low inlet water temperature Polarity will Damage the Circuit Boards DSICombination cutoff valve and the modulating Check ignition wire. Check that lights above Dimensions Table Dimensions Main Assembly Shown Not ShownControl BOX Assembly Front View QTY Description MFG noControl BOX Assembly TOP View Control BOX ASSEMBLY-TOP View Hood Assembly Cantilever ARM Assembly TUB Assembly Back of TUB, & Drain Assembly Lower Assembly Right Side Incoming Plumbing Assembly Incoming Plumbing Parts Lists GAS Pack Assembly Upper WASH, & Rinse ARM Assembly Lower WASH, & Rinse ARM Assembly Steam Coil Assembly Steam Coil Assembly Parts Lists Rinse Tank Assembly Electronic Control Drawer Components RED Green LEDElectrical Diagram 208/240 Volt 60 Hertz 1 Phase