Multiquip STXD6i operation manual FueL safeTy, BaTTeRy safeTy

Page 11

Safety Information

NOTICE

„NeveR run engine without an air fi lter or with a dirty air fi lter. Severe engine damage may occur. Service air fi lter frequently to prevent engine malfunction.

„NeveR tamper with the factory settings of the engine or engine governor. Damage to the engine or equipment can result if operating in speed ranges above the maximum allowable.

fueL safeTy

daNgeR

„dO NOT start the engine near spilled fuel or combustible fl uids. Fuel is extremely fl ammable and its vapors can cause an explosion if ignited.

„aLWays refuel in a well-ventilated area, away from sparks and open fl ames.

„aLWays use extreme caution when working with flammable liquids.

„dO NOT fi ll the fuel tank while the engine is running or hot.

„dO NOT overfi ll tank, since spilled fuel could ignite if it comes into contact with hot engine parts or sparks from the ignition system.

„Store fuel in appropriate containers, in well-ventilated areas and away from sparks and fl ames.

„NeveR use fuel as a cleaning agent.

„dO NOT smoke around or near the equipment. Fire or explosion could result from fuel vapors or if fuel is spilled on a hot engine.

BaTTeRy safeTy

daNgeR

„dO NOT drop the battery. There is a possibility that the battery will explode.

„dO NOT expose the battery to open fl ames, sparks, cigarettes, etc.The battery contains combustible gases and liquids. If these

gases and liquids come into contact with a fl ame or spark, an explosion could occur.

WaRNINg

„aLWays wear safety glasses when handling the battery to avoid eye irritation. The battery contains acids that can cause injury to the eyes and skin.

„Use well-insulated gloves when picking up the battery.

„aLWays keep the battery charged. If the battery is not charged, combustible gas will build up.

„dO NOT charge battery if frozen. Battery can explode. When frozen, warm the battery to at least 61°F (16°C).

„aLWays recharge the battery in a well-ventilated environment to avoid the risk of a dangerous concentration of combustible gases.

„If the battery liquid (dilute sulfuric acid) comes into contact with clothing or skin, rinse skin or clothing immediately with plenty of water.

„If the battery liquid (dilute sulfuric acid) comes into contact with eyes, rinse eyes immediately with plenty of water and contact the nearest doctor or hospital to seek medical attention.

cauTION

„aLWays disconnect the NegaTIve battery terminal before performing service on the equipment.

„aLWays keep battery cables in good working condition. Repair or replace all worn cables.

STXD6i RIDE-ON TROWEL • operation manual —rev. #0 (03/23/12) — page 11

Image 11
Contents Model stxd6i Proposition 65 warning Silicosis Warning Silicosis/respiratory warningsSpecifications are subject to change without notice Table of ContentsPage Completely Training checklistTraining checklist Daily pre-Operation checklist Daily pre-operation checklistSafeTy messages Safety InformationGeNeRaL safeTy Before servicing equipment TROWeL safeTyENgINe safeTy Order Form PT-160„ Use well-insulated gloves when picking up the battery FueL safeTyBaTTeRy safeTy „ NeveR lift trowel with the operator on the machine TRaNspORTINg safeTyTOWINg safeTy LiftingLabel must remain with the engine for its entire life ENvIRONmeNTaL safeTy/decOmmIssIONINgEmIssIONs INfORmaTION Emission control LabelTransporting the trowel Lifting and transportingLifting the trowel Engine Specifications SpecificationsTrowel Specifications This value includes the seat height Table DimensionsTrowel Dimensions Width in. cmGeneral information Components IndicatorsToolbox Compartment Storage for tools Oil Filler Port Remove to add fresh crankcase oil Basic engineHydraulic Oil InspectionEngine Oil Determine if the engine fuel is low Figure „„ The ash content must not exceed 0.01% by volumeFuel Battery Setup SetupStarting the Engine Insert the ignition key into the ignition switch FigureOperation Engine throttle Battery ManagementSafety Interlocks Safety InterlockHydraulic Oil Filter Monitoring Power managementFault Alerting Red Stop Lamp Hydraulic Oil Cooler Fan ControlControl Joystick Result Direction Joystick Directional PositioningBlade Pitch Control Manual Mode Pitch Mode Light is OffSmart Pitch Mode Panning ModeEngine Shutdown Engine ShutDownMaintenance Schedule MaintenanceRadiator/Cooling System Air CleanerAir Cleaner Service Fan Belt Tension Radiator CleaningReplace the engine fuel filter element every 500 hours Changing Engine Oil And FilterFuel Filter Recommended Viscosity GradesEngine Tune-Up Battery/Charging SystemFuel/Water Separator Oil And Fuel LinesLong Term Storage Installing Pans Onto Finisher BladesTroubleshooting Ride-On hydraulic Trowel TroubleshootingWiring? Repair per engine repair manual Dipstick HERE’S HOW to GET Help