Multiquip STXD6i Fuel/Water Separator, Oil And Fuel Lines, Engine Tune-Up, Hydraulic oil filter

Page 34

maintenance

Refer to your engine manual for specific details to perform this operation.

fuel/Water Separator

Inspect the Fuel/Water Separator daily. If the Fuel/Water Separator (Figure 27) has collected a significant amount of water and sediment at the bottom of the cup, it should be drained off. Refer to your engine manual for specific details to perform this operation.

 

FUEL

 

COCK

RETAINING

 

RING

CUP

 

SEDIMENT

Figure 27. Fuel/ Water Separator

Oil And Fuel Lines

1.Check the oil and fuel lines and connections regularly for leaks or damage. Repair or replace as necessary.

2.Replace the oil and fuel lines every two years to maintain the line's performance and flexibility.

CAUTION

NEVER place hands near the belts or fan while the trowel is running.

Engine Tune-Up

At the front of this manual is a “Daily Pre-Operation Checklist”. Make copies of this checklist and use it on a daily basis.

NOTICE

See the engine manual supplied with your machine for appropriate engine maintenance schedule and troubleshooting guide for problems.

ALWAYS disconnect battery cables before attempting any service or maintenance on the ride-on trowel.

hydraulic oil filter

1.Change the hydraulic oil and filter (Figure 28) after the first 100 hours of use then change every 250 hours. Use 10 micron absolute synthetic media filter.

HYDRAULIC

OIL FILTER

Figure 28. Hydraulic Oil Filter

Battery/Charging System

1.Check and clean battery terminals for corrosion.

2.Never attempt to charge a battery that is frozen. The battery can explode unless first allowed to thaw.

3.Disconnect the negative terminal ( - ) of the battery during storage. If unit will be stored where ambient temperature will drop to -15oC or less, remove and store battery in a warm, dry place.

4.Check manufacturer's recommendations for maintaining and charging battery.

page 34 — stxd6i RIDE-ON TROWEL• operation manual — rev. #0 (03/23/12)

Page 33 Page 35
Image 34
Page 33 Page 35
Contents Model stxd6i Proposition 65 warning Silicosis/respiratory warnings Silicosis WarningTable of Contents Specifications are subject to change without noticePage Training checklist Training checklistCompletely Daily pre-operation checklist Daily pre-Operation checklistSafety Information SafeTy messagesGeNeRaL safeTy Order Form PT-160 TROWeL safeTyENgINe safeTy Before servicing equipmentBaTTeRy safeTy FueL safeTy„ Use well-insulated gloves when picking up the battery Lifting TRaNspORTINg safeTyTOWINg safeTy „ NeveR lift trowel with the operator on the machineEmission control Label ENvIRONmeNTaL safeTy/decOmmIssIONINgEmIssIONs INfORmaTION Label must remain with the engine for its entire lifeLifting the trowel Lifting and transportingTransporting the trowel Trowel Specifications SpecificationsEngine Specifications Width in. cm DimensionsTrowel Dimensions This value includes the seat height TableGeneral information Indicators ComponentsToolbox Compartment Storage for tools Basic engine Oil Filler Port Remove to add fresh crankcase oilEngine Oil InspectionHydraulic Oil Fuel „„ The ash content must not exceed 0.01% by volumeDetermine if the engine fuel is low Figure Setup Battery SetupOperation Insert the ignition key into the ignition switch FigureStarting the Engine Safety Interlock Battery ManagementSafety Interlocks Engine throttleHydraulic Oil Cooler Fan Control Power managementFault Alerting Red Stop Lamp Hydraulic Oil Filter MonitoringJoystick Directional Positioning Control Joystick Result DirectionPanning Mode Manual Mode Pitch Mode Light is OffSmart Pitch Mode Blade Pitch ControlEngine ShutDown Engine ShutdownMaintenance Maintenance ScheduleAir Cleaner Service Air CleanerRadiator/Cooling System Radiator Cleaning Fan Belt TensionRecommended Viscosity Grades Changing Engine Oil And FilterFuel Filter Replace the engine fuel filter element every 500 hoursOil And Fuel Lines Battery/Charging SystemFuel/Water Separator Engine Tune-UpInstalling Pans Onto Finisher Blades Long Term StorageTroubleshooting Troubleshooting Ride-On hydraulic TrowelWiring? Repair per engine repair manual Dipstick HERE’S HOW to GET Help
Top Page Image Contents