U-Line 2175BEV, 2275DWRWS, 2175WCOL, 2275DWRWOL, CO2175F, CO2175/CO2275DWR, 2115R CLRCO2175 Mode 5 Off

2010 Potential Problems with HFC-134A IntroductionÉchelon Models 2115R Origins Models 1115RTable of Contents Wiring Diagrams Safety Precautions Safety Alert DefinitionsLine Corporation Limited Warranty Product Liability Policy Leaders In Quality Undercounter RefrigerationWarranty Claims Procedure Serial Number FormatProof of Purchase Parts Listing How to Order Replacement PartsCustomer Call Guide CLR2160 Model Only Refrigeration System Diagnosis Guide Type 1 BlackType 2 White Troubleshooting Troubleshooting Troubleshooting Error Codes ServiceOperation GeneralCLR2160 No ice Too much iceToo little ice Ice not sized to customer satisfactionCLRCO2175 CLRCO2175 Mode 1 Ice Making and Refrigeration ULIN0329A CLRCO2175 Mode 3 Refrigeration and No Ice Making CLRCO2175 Mode 4 Ice harvest No Refrigeration Possible CLRCO2175 Mode 5 Off Service and Repair CLRCO2175 Mode 7 Cleaning No Refrigeration Possible Error code is repeated, the thermistor is Display is showing something other than SP 38, ER or CL Refrigerator not cooling but ice maker workingIce maker not operating-no water flowing over mold 2115R/2175WC/2175BEV/2275DWRR/2175DWRR Review the Following Notes for General Information Thermistor Outage Except Dwrws & 2275ZWCThermistor Outage Dwrws & 2275ZWC Excessive Frost on evaporator Display is showing something other than SP 38 or ERRefrigerator too warm Service and Repair CO2175F/2175RF/CO2175DWR Line Frost Free Refrigeration SystemReed Switch ThermistorsDefrost Storage mode Freeze cycleHarvest cycle Water fill cycleCO2175F Harvest-1 Cycle First 30 Seconds CO2175F Water Fill Cycle CO2175F Freeze Cycle CO2175/2275DWR Harvest-2 Cycle After 30 Seconds CO2175/2275DWR Water Fill Cycle Not making ice This can be caused by poor incoming water quality Service and Repair 1175R/1115R 1175WC/1115WC 1175BEV/ADA24R Error Code It is most likely a refrigeration system issueOperating ENVIRONMENTAL/ Climate Control Requirements Échelon Electronic ControlON/OFF Cabinet LightAdjusting the SET-POINT 2275DWRWS only Adjusting the SET-POINT 2275ZWC/2275ZWCOL only2275ZWCOL Viewing Actual Temperature 2275DWRWS only Viewing Actual Temperature 2275ZWC/2275ZWCOL onlyShowroom Mode Service ModeICE Thickness Adjust Temporary SHUTDOWN/OFFICE ModeForced Defrost Relay StatusError Codes E2 Thermistor 1 is shorted. Not available on CLR2160 Model Thermistor Door Switch Échelon Service Quick Reference Card Échelon Electronic Control Quick Reference Guide Viewing Actual Temperature Origins Electronic ControlOrigins Service Menu Origins Model SelectionOrigins Electronic Control Quick Reference Guide Defrost Information ALL Models Refrigeration System Diagnosis GuideSpecifications COMPRESSOR/COIL SpecificationsCLRCO2175 Refrigerator Coil OHMS-2175DWRWS/2275ZWC 2115R/2175WC/2115WC/2175BEV 2175WRR/2175DWRWSICE Maker Limit Switch CO2175F/2175RF/CO2175DWR1175R/1115R 1175WC/1115WC 1175BEV/ADA24R Adjustments and Repair Échelon Full OverlayAdjusting Door Alignment Notch must face center of doorDoor Alignment Origins Models Checking Door AlignmentAdjusting Drawer Alignment Checking Drawer AlignmentDrawer Removal Minor Adjustment Severe AdjustmentSIDE-TO-SIDE Adjustment FRONT-TO-BACK AdjustmentTOP-TO-BOTTOM and LEFT-TO-RIGHT Adjustment RE-INSTALLATION of Drawer Ice Cube Thickness Adjustment Interval AS RequiredAccessing Evaporator or Drain CO2175F/2175RF Replacing Evaporator FAN Motor CO2175F/2175RFTo access evaporator or drain Replacing Evaporator FAN Motor CO2175DWRReplacing ICE Maker Replacing Mold and Heater CO2175F/CO2175DWR FACTORY-INSTALLED Drain Pump Drain ConnectionGravity Drain Remove 12 screws and back panel LOCALLY-INSTALLED Drain Pump Tools RequiredMaterials Required CLR Drain KIT Available for PurchaseULINS0168A Loose. For the disposal or Water Supply Connection WaterhookupANTI-TIP KIT CLR2160 1 Description CLR2160 2 41993 CLRCO2175 1 Screw, handle included with handle assembly CLRCO2175 2 Compression nut included with water line CLRCO2175 3 Armaflex, 1-5/8 ID included with 2276-CLRCO-S CLRCO2175 4 BF4CO5-S 2175R 1 Screw, handle included with handle assembly 2175R 2 Not 2950-01 Wire connector, 12-pin 2115R 1 Screw, handle included with handle assembly 2115R 2 41993 2175WC/2175WCOL/2175WCOL2 1 2175WC/2175WCOL/2175WCOL2 1 2175WC/2175WCOL /2175WCOL22 Black Stainless Steel 2115WC/2115WCOL/2115WCOL2 1OF2 2115WC/2115WCOL/2115WCOL2 1 2115WC/2115WCOL/2115WCOL2 2 41993 2175BEV/2175BEVOL/2175BEVOL2 1 Overlay Door Stainless Steel 2175BEV/2175BEVOL/2175BEVOL2 2 Black Stainless Steel 2175DWRR/2275DWRR 1 2175DWR-TOP-BLK 2175DWRR/2275DWRR 2 Not 14159-05 Commerical handle SS accesory only 2275DWRWS/2275DWRWOL 1 Not 80-50002-00 Overlay Bracket Assembly 2275DWRWS/2275DWRWOL 2 Item Part No. Description CO2175F 1 Description CO2175F 2 0f CO2175F 2 CO2175F 3 Not 35014 Tape, drain pan heater CO2175F 4 Mold and Heater Assembly 2175RF 1 Black White Stainless Steel 2175RF 2 Solenoid only included with 73002-FFS 2175RF 3 Evaporator Assembly includes heat exchanger CO2175DWR/CO2275DWR 1 Process tube included with 73002-FFS CO2175DWR/CO2275DWR 2 Drawer Front Assembly, top CO2175DWR/CO2275DWR 3 Evaporator Assembly includes heat exchanger CO2275DWR 4 Mold and Heater Assembly 2275ZWC/2275ZWCOL 1 Overlay Stainless Steel 2275ZWC/2275ZWCOL 2 Process tube included with compressor 2275ZWC/2275ZWCOL 3 26100 Display housing 41992 1175R 1 Towel Bar Handle Assembly SS accessory only 1175R 2 Thermistor, quick connect white 1115R 1 Black Stainless Steel 1115R 2 31213 Spacer 1175WC 1 26147 Door Spacer, for Field Reversable Doors 1175WC 2 26058 1115WC 1 Pivot screw, bottom included with hinge assembly 1115WC 2 26059 1175BEV 1 26147 Door Spacer, for Field Reversable Doors 1175BEV 2 26058 ADA24R 1 0F ADA24R 1 0F DescriptionADA24R 2 0F Description Black Stainless Steel This page intentionally left blank CLRCO2175 2115R, 2115WC, 2175R, 2175WC, 2175BEV 2175RF CO2175F ADA24R This page intentionally left blank Product Information About U-LINE