Section 3 - Service and Repair
REPLACING ICE MAKER
1.Unplug unit.
2.Disconnect ice maker wire harness at plug (Figure 60).
3.Disconnect thermistor plug.
4.Remove water inlet tube.
5.Remove front cover.
6.Advance ejector blade to the 3 o’clock position by turning the 5/ 16" hex head on the small brass gear counterclockwise.
7.Remove three screws from wall of freezer housing.
8.Remove ice maker assembly.
9.Install new ice maker assembly.
10.Reconnect plug.
11.Reconnect thermistor plug.
12.Insert water inlet tube.
13.Apply Permagum® to all exit holes.
14.Install back panel.
15.Plug in unit and test.
2010
Potential Problems with HFC-134A
Introduction
Échelon Models 2115R
Origins Models 1115R
Table of Contents
Wiring Diagrams
Safety Precautions
Safety Alert Definitions
Line Corporation Limited Warranty
Product Liability Policy
Leaders In Quality Undercounter Refrigeration
Warranty Claims Procedure
Serial Number Format
Proof of Purchase
Parts Listing
How to Order Replacement Parts
Customer Call Guide
CLR2160 Model Only
Refrigeration System Diagnosis Guide
Type 1 Black
Type 2 White
Troubleshooting
Troubleshooting
Troubleshooting
Error Codes
Service
Operation
General
CLR2160
No ice
Too much ice
Too little ice
Ice not sized to customer satisfaction
CLRCO2175
CLRCO2175 Mode 1 Ice Making and Refrigeration
ULIN0329A
CLRCO2175 Mode 3 Refrigeration and No Ice Making
CLRCO2175 Mode 4 Ice harvest No Refrigeration Possible
CLRCO2175 Mode 5 Off
Service and Repair
CLRCO2175 Mode 7 Cleaning No Refrigeration Possible
Error code is repeated, the thermistor is
Display is showing something other than SP 38, ER or CL
Refrigerator not cooling but ice maker working
Ice maker not operating-no water flowing over mold
2115R/2175WC/2175BEV/2275DWRR/2175DWRR
Review the Following Notes for General Information
Thermistor Outage Except Dwrws & 2275ZWC
Thermistor Outage Dwrws & 2275ZWC
Excessive Frost on evaporator
Display is showing something other than SP 38 or ER
Refrigerator too warm
Service and Repair CO2175F/2175RF/CO2175DWR
Line Frost Free Refrigeration System
Reed Switch
Thermistors
Defrost
Storage mode
Freeze cycle
Harvest cycle
Water fill cycle
CO2175F Harvest-1 Cycle First 30 Seconds
CO2175F Water Fill Cycle
CO2175F Freeze Cycle
CO2175/2275DWR Harvest-2 Cycle After 30 Seconds
CO2175/2275DWR Water Fill Cycle
Not making ice
This can be caused by poor incoming water quality
Service and Repair 1175R/1115R 1175WC/1115WC 1175BEV/ADA24R
Error Code
It is most likely a refrigeration system issue
Operating ENVIRONMENTAL/ Climate Control Requirements
Échelon Electronic Control
ON/OFF
Cabinet Light
Adjusting the SET-POINT 2275DWRWS only
Adjusting the SET-POINT 2275ZWC/2275ZWCOL only
2275ZWCOL
Viewing Actual Temperature 2275DWRWS only
Viewing Actual Temperature 2275ZWC/2275ZWCOL only
Showroom Mode
Service Mode
ICE Thickness Adjust
Temporary SHUTDOWN/OFFICE Mode
Forced Defrost
Relay Status
Error Codes
E2 Thermistor 1 is shorted. Not available on CLR2160
Model Thermistor Door Switch
Échelon Service Quick Reference Card
Échelon Electronic Control Quick Reference Guide
Viewing Actual Temperature
Origins Electronic Control
Origins Service Menu
Origins Model Selection
Origins Electronic Control Quick Reference Guide
Defrost Information ALL Models
Refrigeration System Diagnosis Guide
Specifications
COMPRESSOR/COIL Specifications
CLRCO2175
Refrigerator Coil OHMS-2175DWRWS/2275ZWC
2115R/2175WC/2115WC/2175BEV 2175WRR/2175DWRWS
ICE Maker Limit Switch
CO2175F/2175RF/CO2175DWR
1175R/1115R 1175WC/1115WC 1175BEV/ADA24R
Adjustments and Repair
Échelon Full Overlay
Adjusting Door Alignment
Notch must face center of door
Door Alignment Origins Models
Checking Door Alignment
Adjusting Drawer Alignment
Checking Drawer Alignment
Drawer Removal
Minor Adjustment
Severe Adjustment
SIDE-TO-SIDE Adjustment
FRONT-TO-BACK Adjustment
TOP-TO-BOTTOM and LEFT-TO-RIGHT Adjustment
RE-INSTALLATION of Drawer
Ice Cube Thickness Adjustment
Interval AS Required
Accessing Evaporator or Drain CO2175F/2175RF
Replacing Evaporator FAN Motor CO2175F/2175RF
To access evaporator or drain
Replacing Evaporator FAN Motor CO2175DWR
Replacing ICE Maker
Replacing Mold and Heater CO2175F/CO2175DWR
FACTORY-INSTALLED Drain Pump
Drain Connection
Gravity Drain
Remove 12 screws and back panel
LOCALLY-INSTALLED Drain Pump
Tools Required
Materials Required
CLR Drain KIT Available for Purchase
ULINS0168A
Loose. For the disposal or
Water Supply Connection
Waterhookup
ANTI-TIP KIT
CLR2160 1
Description
CLR2160 2
41993
CLRCO2175 1
Screw, handle included with handle assembly
CLRCO2175 2
Compression nut included with water line
CLRCO2175 3
Armaflex, 1-5/8 ID included with 2276-CLRCO-S
CLRCO2175 4
BF4CO5-S
2175R 1
Screw, handle included with handle assembly
2175R 2
Not 2950-01 Wire connector, 12-pin
2115R 1
Screw, handle included with handle assembly
2115R 2
41993
2175WC/2175WCOL/2175WCOL2 1
2175WC/2175WCOL/2175WCOL2 1
2175WC/2175WCOL /2175WCOL22
Black Stainless Steel
2115WC/2115WCOL/2115WCOL2 1OF2
2115WC/2115WCOL/2115WCOL2 1
2115WC/2115WCOL/2115WCOL2 2
41993
2175BEV/2175BEVOL/2175BEVOL2 1
Overlay Door Stainless Steel
2175BEV/2175BEVOL/2175BEVOL2 2
Black Stainless Steel
2175DWRR/2275DWRR 1
2175DWR-TOP-BLK
2175DWRR/2275DWRR 2
Not 14159-05 Commerical handle SS accesory only
2275DWRWS/2275DWRWOL 1
Not 80-50002-00 Overlay Bracket Assembly
2275DWRWS/2275DWRWOL 2
Item Part No. Description
CO2175F 1
Description
CO2175F 2 0f
CO2175F 2
CO2175F 3
Not 35014 Tape, drain pan heater
CO2175F 4
Mold and Heater Assembly
2175RF 1
Black White Stainless Steel
2175RF 2
Solenoid only included with 73002-FFS
2175RF 3
Evaporator Assembly includes heat exchanger
CO2175DWR/CO2275DWR 1
Process tube included with 73002-FFS
CO2175DWR/CO2275DWR 2
Drawer Front Assembly, top
CO2175DWR/CO2275DWR 3
Evaporator Assembly includes heat exchanger
CO2275DWR 4
Mold and Heater Assembly
2275ZWC/2275ZWCOL 1
Overlay Stainless Steel
2275ZWC/2275ZWCOL 2
Process tube included with compressor
2275ZWC/2275ZWCOL 3
26100 Display housing 41992
1175R 1
Towel Bar Handle Assembly SS accessory only
1175R 2
Thermistor, quick connect white
1115R 1
Black Stainless Steel
1115R 2
31213 Spacer
1175WC 1
26147 Door Spacer, for Field Reversable Doors
1175WC 2
26058
1115WC 1
Pivot screw, bottom included with hinge assembly
1115WC 2
26059
1175BEV 1
26147 Door Spacer, for Field Reversable Doors
1175BEV 2
26058
ADA24R 1 0F
ADA24R 1 0F
Description
ADA24R 2 0F
Description Black Stainless Steel
This page intentionally left blank
CLRCO2175
2115R, 2115WC, 2175R, 2175WC, 2175BEV
2175RF
CO2175F
ADA24R
This page intentionally left blank
Product Information
About U-LINE