Cornelius 326142000 ‘‘ERROR 1’’ or ‘‘ERROR2’’ Fault Message Goes on During, List of Figures

TABLE OF CONTENTS (cont’d)

Page

ALL FAULT MESSAGES NOT OPERATING	62
‘‘CO2 OUT’’ FAULT MESSAGE GOES ON DURING OPERATION	63
‘‘H2O OUT’’ FAULT MESSAGE GOES ON DURING OPERATION	63
‘‘SYRUP 1’’ OR ‘‘SYRUP 2’’ FAULT MESSAGE GOES ON DURING
OPERATION	63
‘‘ERROR 1’’ OR ‘‘ERROR2’’ FAULT MESSAGE GOES ON DURING
OPERATION	63
FREEZE CYLINDER AUTOMATIC DEFROST CYCLE DOES NOT
OPERATE	63
UNIT DOES NOT GO OFF AUTOMATIC DEFROST CYCLE	63
MANUAL DEFROST CYCLE DOES NOT OPERATE WHEN ‘‘DEFROST’’
SWITCH IS PRESSED	63
TROUBLESHOOTING PRODUCT BLENDER TANKS AND CARBONATOR. . .	64
DEFROST CYCLE DOES NOT CANCEL AFTER PRESSING ‘‘CANCEL
DEFROST ’’ SWITCH	64
CARBONATOR WATER PUMP MOTOR WILL NOT OPERATE	64
CARBONATOR WATER PUMP WILL NOT SHUT OFF	64
ERRATIC CARBONATOR WATER PUMP CYCLING	65
TROUBLESHOOTING DISPENSED PRODUCT	65
BRIX (WATER–TO–SYRUP) ‘‘RATIO’’ TOO LOW	65
BRIX (WATER–TO–SYRUP) ‘‘RATIO’’ TOO HIGH	65
IMPROPER PRODUCT DISPENSED	65
PRODUCT WILL NOT DISPENSE OUT OF DISPENSING VALVE, IN ONLY
SMALL AMOUNTS, OR ONLY LIQUID	65
FREEZE CYLINDER DOES NOT REFILL AT ALL TIMES WHEN
DISPENSING	65
FROZEN PRODUCT CONSISTENCY VARIES EXCESSIVELY	66
CYLINDER FREEZE–UP	66
ACCESSORIES AND TOOLS	66
ACCESSORIES	66
GENERIC FLAVOR TABS	66
SERVICE TOOLS	66
WARRANTY	78
LIST OF FIGURES
FIGURE 1. FCB (SOLID-STATE) POST-MIX TWO-FLAVOR DISPENSER . . . .	1
FIGURE 2. FLOW DIAGRAM	4
FIGURE 3. FREEZE CYLINDER CUTAWAY VIEW	7
FIGURE 4. BEATERS AND SCRAPER BLADES INSTALLATION	8
FIGURE 5. OPERATING CONTROLS	30
FIGURE 6. UNIT INTERNAL COMPONENTS	31
FIGURE 7. SELF-CLOSING DISPENSING VALVE	32
FIGURE 8. SERVICING BEATER DRIVE SHAFT SEAL ASSEMBLY	32
FIGURE 9. CONTROL PANEL	37
FIGURE 10. MASTER AND RELAY CIRCUIT BOARDS	39
FIGURE 11. LIQUID CHECK VALVE ASSEMBLY	48
v
	326142000