Zanussi ZCG 8021 manual What is wrong and why?, Check

Page 37

Z C G 8 0 2 1

What is wrong and why?

We strongly recommend that you carry out the following checks on your appliance before calling a Service Engineer.

Problem

The oven, grill or hotplate will not light.

Check

If only the hotplate burners will not light make sure that the burner

lparts have been replaced correctly.

If you cannot hear any sparking when you press the ignition button there may be a fault with the electrical supply. First check the socket by trying out another piece of electrical equipment in it. If that works, renew the fuse in the plug. Use a 3 amp fuse. If the fuse 'blows' again there is a fault on the appliance. Do not use a fuse with a rating higher than 3 amps. Do not carry out other electrical work. Unplug the appliance and tell your installer. If the appliance will not light because there is an electrical power failure such as a power cut, you cannot use the main oven. All other burners may be lit with a match.

Check that there is not a problem with your gas supply. You can do this by making sure that other gas appliances such as your central heating or gas fire are working.

Problem

Food is cooking too quickly or too slowly.

lCheck

Check that you are using the recommended gas marks and shelf positions. Be prepared to adjust the gas mark up or down to get the results you want.

Problem

The oven is not cooking evenly.

Check

Check that the appliance is installed properly and is level. Check that the oven roof is pushed fully back into position. Check that you are using the recommended size baking trays.

If you are cooking a large item be prepared to turn it round during

lcooking.

All food in the second oven should be turned round.

What is wrong and why?

37

Image 37

Contents ZCG Introduction For your safetyContents Hotplate Lighting the applianceGrill Grill/second ovenSecond oven To turn off any burner Main ovenOven light Grill Prior to using the grillHeat control Cooking positionsPositioning food on the grid PreheatingGrill pan and handle Grill pan is supplied with a removable handleBurner sizes HotplateHotplate control knobs turn Anticlockwise from OFF to HighTake extra care when you are deep fat frying. Do Take care to avoid burns and scalds when youCatches fire, leave it where it is and turn off all If you are using a Wok we recommend it has a flatHelpful hints Heat zones OvensOven shelves Baking trays and dishes Condensation RoastingOven cooking chart Main oven Mins. per ½kg 1lb and 25 mins 30 40 mins Base Medium Oven cooking chart Second ovenLamb Shelf on Medium Base Well DoneFruit pie shortcrust 25 35 mins Baked custard 50 60 mins 45 60 minsTo use the Timer Electronic timerTo set the time of day Turn the selector knob to Manual then turn to ClockClock. Turn Setting knob Either direction Setting the controls for automatic useAutomatic control G 8 0 2 How long will Turn the selector knob to Food take Cooked by? Switch off showsTo cook? What time do Turn the selector knob to You wantHints and tips for automatic cooking Food preparation slow cooking Slow cookingPlease note There is no slow cook on the second oven Cover food with tight fitting lid or tin foil Do not cook casseroles over 2.7kg 6lbThaw thoroughly before cooking Left over food should be cooled quickly and refrigeratedCare and cleaning For your safety Cap to crown When replacing hotplate burner partsGrill and top oven furniture It using mild abrasives or a soap filled pad such as BrilloMain oven To carry out a cleaning cycle Remove the oven shelves Main oven cleaning cycleGeneral To remove the outer glass Cleaning between the outer and inner door glassInstalling the appliance Cleaning The Door GlassLocation Positioning Appliance dimensionsHeight to hotplate 900mm 920mm Width 594mm DepthConnecting to the electricity supply General information For your safetyMoving your appliance Replacing the Main Oven light bulb Check What is wrong and why?Probably a fault Name Model Number Serial Number C. Number Service and spare partsCustomer Care Department Installation Instructions Connections DimensionsGrill HotplateMain Oven Important Safety RequirementsSecond Oven GeneralAFig.1b Location of ApplianceLevelling the Appliance Parts RequiredFitting the Stability Bracket Connection to the Electricity Supply Connecting to GASChecking the Grill Pressure TestingChecking the Hotplate Checking the Main Oven Checking the Main Oven ControlsAutomatic Operation Checking the Main Oven Light Checking the Second OvenGeneral Note G 8 0 2 1 Guarantee ConditionsT E S Part Number311697900