Southbend SEZ/3 manual Table of Contents

Page 3

SEZ SERIES COUNTERTOP STEAMERS

TABLE OF CONTENTS

Congratulations! You have purchased one of the finest pieces of heavy-duty commercial cooking equipment on the market.

You will find that your new equipment, like all Southbend equipment, has been designed and manufactured to meet the toughest standards in the industry. Each piece of Southbend equipment is carefully engineered and designs are verified through laboratory tests and field installations. With proper care and field maintenance, you will experience years of reliable, trouble-free operation. For best results, read this manual carefully.

RETAIN THIS MANUAL FOR FUTURE REFERENCE.

Table of Contents

 

Specifications

4

Installation

6

Operation

12

Cooking Hints

13

Cleaning

16

Troubleshooting

18

Parts

40

Read these instructions carefully before attempting installation. Installation and initial startup should be performed by a qualified installer. Unless the installation instructions for this product are followed by a qualified service technician (a person experienced in and knowledgeable with the installation of commercial gas an/or electric cooking equipment) then the terms and conditions on the Manufacturer’s Limited Warranty will be rendered void and no warranty of any kind shall apply.

In the event you have questions concerning the installation, use, care, or service of the product, write to:

Technical Service Department

Southbend

1100 Old Honeycutt Road

Fuquay-Varina, North Carolina 27526 USA The serial plate is located on the right side of the unit near the back and top.

OPERATOR’S MANUAL 1183437

PAGE 3

Page 2 Page 4
Image 3
Page 2 Page 4
Contents For Models SEZ/3 & SEZ/5 Built After February 15 Super Simple Steam SEZ Series Countertop SteamersSafety Precautions Table of Contents Dimensions SpecificationsDrain Requirements Construction SpecificationsElectrical Requirements Water RequirementsUnpacking InstallationInstallation Bottom View Electrical Connection Water Connection Drain Connection Shutdown OperationStartup OperationCooking Hints Cooking TipsSuggested Cooking Times Cooking Hints SEZ Series Countertop Steamers Cleaning Daily CleaningPeriodic Cleaning Semiannual Cleaning Troubleshooting Troubleshooting KEYTroubleshooting Figures and Procedures Unit Not Heating Up, on Light Not Lit Disconnect Power AT Circuit BreakerTroubleshooting Excessive Steam Coming from Pressure Relief Vent OK? Service Request Light Comes On During OperationBuzzer Does Not Come On Voltage Check at Control Panel Fuse Block Disconnect Power AT Circuit BreakerHeating Element Resistance Check at Contactor Do not Remove Heating Element Lead Wires for this TestMain Fuse Replacement Power Switch Continuity Check Contactor and MOV Check Timer and Buzzer Check Door Switch Continuity Check Float Switch Continuity Check Controller Check Water Solenoid Check Pressure Switch Check High-Limit Thermostats Check Electric Schematic for 208, 220, and 240 Volt Model SEZ/3 Electric Schematic for 480 Volt Model SEZ/3 Electric Schematic for 208, 220, and 240 Volt Model SEZ/5 Electric Schematic for 480 Volt Model SEZ/5 Parts Index of Parts DiagramsCavity and Heater Parts Control Panel Parts Rear View See parts list on previous Control Panel Parts Front and Isometric Views Door Assembly Parts Water Inlet and Drain Parts See parts list on previous Float Tank Parts See parts list on previous 1514 SEZ Series Countertop Steamers SEZ Series Countertop Steamers Super Simple Steam SEZ Series Countertop Steamers
Top Page Image Contents