Southbend SEZ/3 manual Super Simple Steam SEZ Series Countertop Steamers

Page 1

IMPORTANT FOR FUTURE REFERENCE

Please complete this information and retain this manual for the life of the equipment:

Model #: __________________________

Serial #: __________________________

Date Purchased: ___________________

OPERATOR’S MANUAL

Super Simple Steam

SEZ Series Countertop Steamers

For Models SEZ/3 & SEZ/5 Built After February 15, 2001

Model SEZ/3

!WARNING

Improper installation, operation, service, or maintenance can cause property damage, injury, or death.

Read this manual thoroughly before installing and operating this equipment.

1100 Old Honeycutt Road, Fuquay-Varina, NC 27526

(800) 348-2558 or (919) 552-9161 • FAX (800) 348-2558 or (919) 552-9798

MANUAL 1183437	COUNTERTOP STEAMER
$18.00	MANUAL SECTION ST

Image 1

Contents For Models SEZ/3 & SEZ/5 Built After February 15 Super Simple Steam SEZ Series Countertop SteamersSafety Precautions Table of Contents Dimensions SpecificationsElectrical Requirements Construction SpecificationsWater Requirements Drain RequirementsUnpacking InstallationInstallation Bottom View Electrical Connection Water Connection Drain Connection Startup OperationOperation ShutdownCooking Tips Cooking HintsSuggested Cooking Times Cooking Hints SEZ Series Countertop Steamers Daily Cleaning CleaningPeriodic Cleaning Semiannual Cleaning Troubleshooting KEY TroubleshootingTroubleshooting Figures and Procedures Unit Not Heating Up, on Light Not Lit Disconnect Power AT Circuit BreakerTroubleshooting Excessive Steam Coming from Pressure Relief Vent OK? Service Request Light Comes On During OperationBuzzer Does Not Come On Voltage Check at Control Panel Fuse Block Disconnect Power AT Circuit BreakerHeating Element Resistance Check at Contactor Do not Remove Heating Element Lead Wires for this TestMain Fuse Replacement Power Switch Continuity Check Contactor and MOV Check Timer and Buzzer Check Door Switch Continuity Check Float Switch Continuity Check Controller Check Water Solenoid Check Pressure Switch Check High-Limit Thermostats Check Electric Schematic for 208, 220, and 240 Volt Model SEZ/3 Electric Schematic for 480 Volt Model SEZ/3 Electric Schematic for 208, 220, and 240 Volt Model SEZ/5 Electric Schematic for 480 Volt Model SEZ/5 Parts Index of Parts DiagramsCavity and Heater Parts Control Panel Parts Rear View See parts list on previous Control Panel Parts Front and Isometric Views Door Assembly Parts Water Inlet and Drain Parts See parts list on previous Float Tank Parts See parts list on previous 1514 SEZ Series Countertop Steamers SEZ Series Countertop Steamers Super Simple Steam SEZ Series Countertop Steamers