Southbend SEZ/3 manual Control Panel Parts Front and Isometric Views

Page 44

PARTS

PARTS

SEZ SERIES COUNTERTOP STEAMERS

Control Panel Parts (Front and Isometric Views)

6

5	7

4

8

3

2

1

9

10

11

NOTE: The entire Control Panel Assembly can be ordered as part number 1183428.

Key	Part Number	Qty	Description
1	1178331	1	Switch, door
2	1178338	1	Retaining ring
3	1179932	1	Spring, retaining
4	1178388	1	Valve lever weld assembly
5	1177770	1	Valve lever bushing
6	1181513	1	Polypanel with timer
7	1181529	1	Panel, control, weld assembly
8	1170337	1	Knob
9	1178270	1	Switch, actuator rod
10	1178339	1	Washer
11	1178347	2	Seal, shaft

PAGE 44

OPERATOR’S MANUAL 1183437

Image 44

Contents Super Simple Steam SEZ Series Countertop Steamers For Models SEZ/3 & SEZ/5 Built After February 15Safety Precautions Table of Contents Specifications DimensionsConstruction Specifications Electrical RequirementsWater Requirements Drain RequirementsInstallation UnpackingInstallation Bottom View Electrical Connection Water Connection Drain Connection Operation StartupOperation ShutdownSuggested Cooking Times Cooking HintsCooking Tips Cooking Hints SEZ Series Countertop Steamers Periodic Cleaning CleaningDaily Cleaning Semiannual Cleaning Troubleshooting Figures and Procedures TroubleshootingTroubleshooting KEY Disconnect Power AT Circuit Breaker Unit Not Heating Up, on Light Not LitTroubleshooting Excessive Steam Coming from Pressure Relief Vent Service Request Light Comes On During Operation OK?Buzzer Does Not Come On Disconnect Power AT Circuit Breaker Voltage Check at Control Panel Fuse BlockDo not Remove Heating Element Lead Wires for this Test Heating Element Resistance Check at ContactorMain Fuse Replacement Power Switch Continuity Check Contactor and MOV Check Timer and Buzzer Check Door Switch Continuity Check Float Switch Continuity Check Controller Check Water Solenoid Check Pressure Switch Check High-Limit Thermostats Check Electric Schematic for 208, 220, and 240 Volt Model SEZ/3 Electric Schematic for 480 Volt Model SEZ/3 Electric Schematic for 208, 220, and 240 Volt Model SEZ/5 Electric Schematic for 480 Volt Model SEZ/5 Index of Parts Diagrams PartsCavity and Heater Parts Control Panel Parts Rear View See parts list on previous Control Panel Parts Front and Isometric Views Door Assembly Parts Water Inlet and Drain Parts See parts list on previous Float Tank Parts See parts list on previous 1514 SEZ Series Countertop Steamers SEZ Series Countertop Steamers Super Simple Steam SEZ Series Countertop Steamers