Southbend SEZ/3 manual High-Limit Thermostats Check

Page 35

SEZ SERIES COUNTERTOP STEAMERS		TROUBLESHOOTING
	Figure 18
High-Limit Thermostats Check
1.	Note: Allow cavity bottom to cool before performing this test.		TROUBLESHOOTING
2.	Disconnect left thermostat lead wire from wire B62.
3.	Disconnect center thermostat lead wire from wire B57.
4.	Disconnect right thermostat lead wires from wires B58 and B59.
5.	Disconnect remaining thermostat lead wires from each other.
5.	Disconnect remaining thermostat lead wires from each other.
6.	Test each thermostat for continuity. Replace as necessary.
7.	Reconnect all thermostat lead wires.

OPERATOR’S MANUAL 1183437

PAGE 35

Image 35

Contents For Models SEZ/3 & SEZ/5 Built After February 15 Super Simple Steam SEZ Series Countertop SteamersSafety Precautions Table of Contents Dimensions SpecificationsDrain Requirements Construction SpecificationsElectrical Requirements Water RequirementsUnpacking InstallationInstallation Bottom View Electrical Connection Water Connection Drain Connection Shutdown OperationStartup OperationSuggested Cooking Times Cooking HintsCooking Tips Cooking Hints SEZ Series Countertop Steamers Periodic Cleaning CleaningDaily Cleaning Semiannual Cleaning Troubleshooting Figures and Procedures TroubleshootingTroubleshooting KEY Unit Not Heating Up, on Light Not Lit Disconnect Power AT Circuit BreakerTroubleshooting Excessive Steam Coming from Pressure Relief Vent OK? Service Request Light Comes On During OperationBuzzer Does Not Come On Voltage Check at Control Panel Fuse Block Disconnect Power AT Circuit BreakerHeating Element Resistance Check at Contactor Do not Remove Heating Element Lead Wires for this TestMain Fuse Replacement Power Switch Continuity Check Contactor and MOV Check Timer and Buzzer Check Door Switch Continuity Check Float Switch Continuity Check Controller Check Water Solenoid Check Pressure Switch Check High-Limit Thermostats Check Electric Schematic for 208, 220, and 240 Volt Model SEZ/3 Electric Schematic for 480 Volt Model SEZ/3 Electric Schematic for 208, 220, and 240 Volt Model SEZ/5 Electric Schematic for 480 Volt Model SEZ/5 Parts Index of Parts DiagramsCavity and Heater Parts Control Panel Parts Rear View See parts list on previous Control Panel Parts Front and Isometric Views Door Assembly Parts Water Inlet and Drain Parts See parts list on previous Float Tank Parts See parts list on previous 1514 SEZ Series Countertop Steamers SEZ Series Countertop Steamers Super Simple Steam SEZ Series Countertop Steamers