Southbend SEZ/3 manual Control Panel Parts Rear View

Page 42

PARTS

SEZ SERIES COUNTERTOP STEAMERS

Control Panel Parts (Rear View)

See drawing on following page.

NOTE: The entire Control Panel Assembly can be ordered as part number 1181543.

Key

Part Number

Qty

Description

1

1175712

1

Buzzer assembly

2

1183420

1

Controller

3

1146320

6

Screw, 6-32x1, round hd

4

1178331

1

Switch, door

5

1177396

2

Locknut, 6-32 ss

6

1183430

4

Screw, 10-32x1/4, ss, rnd, hd

7

1146398

3

Screw, 6-32x3/8, ss, phil pan hd

8

1178391

1

Fuseblock, control

9

1183423

1

Plate, control panel

10

1178535

1

Switch, power

11

1177865

1

Nut, hex, 5/8-18, brass

12

1178549

1

Screw, set

13

1178276

1

Cam actuator

14

1178329

1

Light, indicating, amber clip lens

15

1178330

1

Light, indicating, red clip lens

16

1183426

1

Terminal block

17

1183425

1

Gasket, control

18

1178341

1

Timer, mechanical

19

6600430

1

Locknut

PARTS

PAGE 42

OPERATOR’S MANUAL 1183437

Page 41 Page 43
Image 42
Page 41 Page 43
Contents Super Simple Steam SEZ Series Countertop Steamers For Models SEZ/3 & SEZ/5 Built After February 15Safety Precautions Table of Contents Specifications DimensionsWater Requirements Construction SpecificationsElectrical Requirements Drain RequirementsInstallation UnpackingInstallation Bottom View Electrical Connection Water Connection Drain Connection Operation OperationStartup ShutdownCooking Hints Cooking TipsSuggested Cooking Times Cooking Hints SEZ Series Countertop Steamers Cleaning Daily CleaningPeriodic Cleaning Semiannual Cleaning Troubleshooting Troubleshooting KEYTroubleshooting Figures and Procedures Disconnect Power AT Circuit Breaker Unit Not Heating Up, on Light Not LitTroubleshooting Excessive Steam Coming from Pressure Relief Vent Service Request Light Comes On During Operation OK?Buzzer Does Not Come On Disconnect Power AT Circuit Breaker Voltage Check at Control Panel Fuse BlockDo not Remove Heating Element Lead Wires for this Test Heating Element Resistance Check at ContactorMain Fuse Replacement Power Switch Continuity Check Contactor and MOV Check Timer and Buzzer Check Door Switch Continuity Check Float Switch Continuity Check Controller Check Water Solenoid Check Pressure Switch Check High-Limit Thermostats Check Electric Schematic for 208, 220, and 240 Volt Model SEZ/3 Electric Schematic for 480 Volt Model SEZ/3 Electric Schematic for 208, 220, and 240 Volt Model SEZ/5 Electric Schematic for 480 Volt Model SEZ/5 Index of Parts Diagrams PartsCavity and Heater Parts Control Panel Parts Rear View See parts list on previous Control Panel Parts Front and Isometric Views Door Assembly Parts Water Inlet and Drain Parts See parts list on previous Float Tank Parts See parts list on previous 1514 SEZ Series Countertop Steamers SEZ Series Countertop Steamers Super Simple Steam SEZ Series Countertop Steamers
Top Page Image Contents