Southbend SEZ/3 manual Door Assembly Parts

Page 45

SEZ SERIES COUNTERTOP STEAMERS

PARTS

Door Assembly Parts

6

7

5

4

3

2

			1

	Key	Part Number		Qty	Description
	Key	Model SEZ/3	Model SEZ/5	Qty	Description
		Model SEZ/3	Model SEZ/5
	1	1177317	1177317	1	Latch assembly
	2	1177080	1177080	1	Cast striker
	3	1178171	1181018	1	Door insulation block
	4	1178105	1181016	1	Panel assembly, inner door
	5	1178096	1181010	1	Gasket, door
	6	1178106	1181001	1	Gasket rtnr pnl	PARTS
	7	1173224	1173224	1	Screw, 1/2-20 x 5/8 s, slot trs	PARTS
	7	1173224	1173224	1	Screw, 1/2-20 x 5/8 s, slot trs
	1-7	1178167	1181015	1	Complete door assembly

OPERATOR’S MANUAL 1183437

PAGE 45

Image 45

Contents For Models SEZ/3 & SEZ/5 Built After February 15 Super Simple Steam SEZ Series Countertop SteamersSafety Precautions Table of Contents Dimensions SpecificationsElectrical Requirements Construction SpecificationsWater Requirements Drain RequirementsUnpacking InstallationInstallation Bottom View Electrical Connection Water Connection Drain Connection Startup OperationOperation ShutdownCooking Hints Cooking TipsSuggested Cooking Times Cooking Hints SEZ Series Countertop Steamers Cleaning Daily CleaningPeriodic Cleaning Semiannual Cleaning Troubleshooting Troubleshooting KEYTroubleshooting Figures and Procedures Unit Not Heating Up, on Light Not Lit Disconnect Power AT Circuit BreakerTroubleshooting Excessive Steam Coming from Pressure Relief Vent OK? Service Request Light Comes On During OperationBuzzer Does Not Come On Voltage Check at Control Panel Fuse Block Disconnect Power AT Circuit BreakerHeating Element Resistance Check at Contactor Do not Remove Heating Element Lead Wires for this TestMain Fuse Replacement Power Switch Continuity Check Contactor and MOV Check Timer and Buzzer Check Door Switch Continuity Check Float Switch Continuity Check Controller Check Water Solenoid Check Pressure Switch Check High-Limit Thermostats Check Electric Schematic for 208, 220, and 240 Volt Model SEZ/3 Electric Schematic for 480 Volt Model SEZ/3 Electric Schematic for 208, 220, and 240 Volt Model SEZ/5 Electric Schematic for 480 Volt Model SEZ/5 Parts Index of Parts DiagramsCavity and Heater Parts Control Panel Parts Rear View See parts list on previous Control Panel Parts Front and Isometric Views Door Assembly Parts Water Inlet and Drain Parts See parts list on previous Float Tank Parts See parts list on previous 1514 SEZ Series Countertop Steamers SEZ Series Countertop Steamers Super Simple Steam SEZ Series Countertop Steamers