Southbend SEZ/3 manual Main Fuse Replacement

Page 26

TROUBLESHOOTING

TROUBLESHOOTING

SEZ SERIES COUNTERTOP STEAMERS

Figure 9

Main Fuse Replacement

Shown with Rear Cover Removed

Water Inlet Connection

Drain Connection

Main Fuse Block

3/4" Conduit Fitting Hole

1.DISCONNECT POWER AT CIRCUIT BREAKER.

2.Remove rear cover from unit.

3.Check fuses for continuity.

4.Replace as necessary.

PAGE 26

OPERATOR’S MANUAL 1183437

Image 26

Contents Super Simple Steam SEZ Series Countertop Steamers For Models SEZ/3 & SEZ/5 Built After February 15Safety Precautions Table of Contents Specifications DimensionsWater Requirements Construction SpecificationsElectrical Requirements Drain RequirementsInstallation UnpackingInstallation Bottom View Electrical Connection Water Connection Drain Connection Operation OperationStartup ShutdownSuggested Cooking Times Cooking HintsCooking Tips Cooking Hints SEZ Series Countertop Steamers Periodic Cleaning CleaningDaily Cleaning Semiannual Cleaning Troubleshooting Figures and Procedures TroubleshootingTroubleshooting KEY Disconnect Power AT Circuit Breaker Unit Not Heating Up, on Light Not LitTroubleshooting Excessive Steam Coming from Pressure Relief Vent Service Request Light Comes On During Operation OK?Buzzer Does Not Come On Disconnect Power AT Circuit Breaker Voltage Check at Control Panel Fuse BlockDo not Remove Heating Element Lead Wires for this Test Heating Element Resistance Check at ContactorMain Fuse Replacement Power Switch Continuity Check Contactor and MOV Check Timer and Buzzer Check Door Switch Continuity Check Float Switch Continuity Check Controller Check Water Solenoid Check Pressure Switch Check High-Limit Thermostats Check Electric Schematic for 208, 220, and 240 Volt Model SEZ/3 Electric Schematic for 480 Volt Model SEZ/3 Electric Schematic for 208, 220, and 240 Volt Model SEZ/5 Electric Schematic for 480 Volt Model SEZ/5 Index of Parts Diagrams PartsCavity and Heater Parts Control Panel Parts Rear View See parts list on previous Control Panel Parts Front and Isometric Views Door Assembly Parts Water Inlet and Drain Parts See parts list on previous Float Tank Parts See parts list on previous 1514 SEZ Series Countertop Steamers SEZ Series Countertop Steamers Super Simple Steam SEZ Series Countertop Steamers