321 Studios FLF110D60E, FLF110D48E, FH110D48E warranty Cleaner Connection, Electronic Blower Control

Page 15

FIGURE 7

ELECTRONIC BLOWER CONTROL

THERMOSTAT

CONNECTIONS

HEATING BLOWER

OFF DELAY

ADJUSTMENT

IN SECONDS.

HUMIDIFIER

CONNECTION

HEATING BLOWER

SPEED CONNECTION

COOLING BLOWER

SPEED CONNECTION

TRANSFORMER 24V

SECONDARY

CONNECTIONS

3 AMP FUSE

OIL PRIMARY T-T

CONNECTIONS

LINE VOLTAGE

CONNECTION (HOT)

UNUSED BLOWER MOTOR

SPEED CONNECTIONS

LINE VOLTAGE

CONNECTION (COM, L2)

ELECTRIC AIR	MIS-1819
CLEANER CONNECTION

Manual 2100-422 Page 13

Image 15

Contents OIL Furnace Installation Instructions Contents For More INFORMATION, Contact These Publishers Getting Other Information and PublicationsEquipment Selection Locating the FurnaceMinimum Clearances Specification Sheet Supply Specification Sheet FC085 Model Dimensions Specification SheetInstallation Installing the FurnaceInstalling a Cooling Unit Instruments Required for Proper Setup of the FurnaceElectrical Data WiringFactory Wiring Field WiringTypical Unit Setup FLF Unit Shown I m n e y Typical Single Inside Tank Installation OIL Line PipingBeckett AFG OIL Burner Beckett Cleancut OIL Pump Beckett Solid State IgniterBeckett R7184B Primary Control Beckett R7184B Primary Operational Guide Electronic Blower Control Cleaner ConnectionBurner Setup and Adjustment Procedures Furnace DataPreparation Steps Combustion Diagnosis Combustion Adjustment StepsSmoke Test Short Form Adjustment ProcedureFinal Checks Check DraftTypical Smoke CO2 Chart with Adjustment Range High Air Settings Low Bacharach Smoke NumberPressure Gauge Connection to Bleed Port No Fuel OIL Efficiency Chart NET Stack TEMP. Degrees F Recommended START-UP SettingsCorrelation of Percent of CO2, O2 Reserve AIR Combustion AIR Requirements GUN Assembly AdjustmentRemoving GUN Assembly Electrode AdjustmentsCombination AIR Boot Assembly Combustion AIR Boot AssemblyAppliances Located in Confined Spaces Square Feet Required to Qualify AS Unconfined SpaceALL AIR from Inside Building Minimum Ventilation Openings ALL Ventilation AIR from OutdoorsAppliances Located in Confined Spaces ALL AIR from Outdoors MIS-1338 Vertical Venting Louvers and GrillesVenting Options Thermostat200 Typical Installation of FR26 FR27 Filter Racks Typical Installation of FR25 Filter KITFilter Sizes for OIL Furnaces LO-BOY Models Filter Locations Filter Installation LO-BOY ModelsFinal Inspection and Test Service HintsLubrication Inspect AIR FilterRemoval of Burner only Combination Combustion CHAMBER/BURNER Mounting SystemTo Remove Burner only To Remove the Entire Combustion Chamber Mounting SystemRemoval of Entire Combustion Chamber Mounting System Cleaning of the Heat Exchanger Common Causes of TroubleCare of Finish Chart FLF/FLR085D36E Data Chart FH085D36E DataChart FH110D48E Data Chart FH110D60E DataChart FC085D36E Data Chart FLR140D60E DataUnit FH Series Wiring DiagramCond Cond Unit