Circuit Breakers
To protect the generator from an overload, a
Lubrication Oil
Fill the engine crankcase with lubricating oil through the filler hole, but DO NOT overfill. Make sure the generator is level. and verify that the oil level is maintained between the two notches (Figure 17) on the dipstick. See Table 8 for proper selection of engine oil.
DCA-15SPXU4 — SETUP
Fuel Check
DANGER - EXPLOSION/FIRE HAZARDS
Fuel spillage on a hot engine can cause a fire or explosion. If fuel spillage occurs, wipe up the spilled fuel completely to prevent fire hazards. NEVER smoke around or near the generator.
Figure 17. Engine Oil Dipstick
When checking the engine oil, be sure to check if the oil is clean. If the oil is not clean, drain the oil by removing the oil drain plug, and refill with the specified amount of oil as outlined in the Isuzu Engine Owner's Manual. Oil should be warm before draining.
Other types of motor oils may be substituted if they meet the following requirements:
■API Service Classification CC/SC
■API Service Classification CC/SD
■API Service Classification CC/SE
■API Service Classification CC/SF
Refilling the Fuel System
CAUTION - REFUELINGTHE GENERATOR
ONLY properly trained personel who have read and understand this section should refill the fuel tank system.
This generator has an internal fuel tank located inside the trailer frame and may also be equipped with an optional environmental fuel tank (Figure 18). ALWAYS fill the fuel tanks with clean fresh #2 diesel fuel. DO NOT fill the fuel tanks beyond their capacities.
Pay attention to the fuel tank capacity when replenishing fuel.The fuel tank cap must be closed tightly after filling. Handle fuel in a safety container. If the container does not have a spout, use a funnel. Wipe up any spilled fuel immediately.
| Table 8. Recommended Motor Oil |
|
| ||||||||
F | C |
|
|
| OIL: SAE |
|
|
|
| ||
|
|
|
|
|
|
|
|
| |||
122 | 50 |
|
|
|
|
|
|
|
|
| |
104 | 40 | 10W40 | 30 | OIL | 5W30 | 10W/40 | 15W30 | 10W30 | 10W | 20W40 | |
86 | 30 | ||||||||||
|
|
|
|
|
|
|
|
| |||
68 | 20 |
|
|
|
|
|
|
|
|
| |
50 | 10 |
|
|
|
|
|
|
|
|
| |
32 | 0 |
|
|
|
|
|
|
|
|
| |
|
|
|
|
|
|
|
|
| |||
|
| ARCTIC |
|
|
|
|
|
| |||
|
|
|
|
|
|
|
| ||||
|
|
|
|
|
|
|
|
| |||
15 | WHISPERWATT | MQPOWER |
ENVIRONMENTAL
FUEL TANK
(OPTION)