Multiquip operation manual DCA-36SPX Safety Message Alert Symbols, Hazard Symbols

Page 8

DCA-36SPX — SAFETY MESSAGE ALERT SYMBOLS

FORYOUR SAFETY AND THE SAFETY OF OTHERS!

HAZARD SYMBOLS

Safety precautions should be followed at all times when operating this equipment. Failure to read and understand the Safety Messages and Operating Instructions could result in injury to yourself and others.

This Owner's Manual has been

developed to provide complete

NOTE instructions for the safe and efficient operation of the MQ Power Model DCA-36SPX

Whisperwatt™ Generator.

Before using this generator, ensure that the operating individual has read and understands all instructions in this manual.

SAFETY MESSAGE ALERT SYMBOLS

The three (3) Safety Messages shown below will inform you about potential hazards that could injure you or others. The Safety Messages specifically address the level of exposure to the operator, and are preceded by one of three words: DANGER, WARNING, or CAUTION.

DANGER

You WILL be KILLED or SERIOUSLY injured if you do not follow directions.

WARNING

You COULD be KILLED or SERIOUSLY injured if you do not follow directions.

CAUTION

You CAN be injured if you do not follow directions

Potential hazards associated with the operation of this equipment will be referenced with "Hazard Symbols" which appear throughout this manual, and will be referenced in conjunction with Safety "Message Alert Symbols".

WARNING - LETHAL EXHAUST GASES

Gasoline engine exhaust gases contain poisonous carbon monoxide. This gas is colorless and odorless, and can cause DEATH if inhaled. NEVER operate this

equipment in a confined area or enclosed structure that does not provide ample free flow air.

WARNING - EXPLOSIVE FUEL

Gasoline is extremely flammable, and its vapors can cause an explosion if ignited. DO NOT start the engine near spilled fuel or combustible fluids. DO NOT fill the fuel tank while the engine is running or hot.

DO NOT overfill tank, since spilled fuel could ignite if it comes into contact with hot engine parts or sparks from the ignition system. Store fuel in approved containers, in well-ventilated areas and away from sparks and flames. NEVER use fuel as a cleaning agent.

WARNING - BURN HAZARDS

Engine components can generate extreme heat.To prevent burns, DO NOT touch these areas while the engine is running or immediately after operations. NEVER operate the engine with heat shields or heat guards removed.

DANGER - ELECTROCUTION HAZARDS

During operation of this generator, there exists the possibility of electrocution, electrical shock or burn, which can cause severe bodily harm or even DEATH!

PAGE 8 — DCA-36SPX— OPERATION AND PARTS MANUAL — REV. #1 (04/14/10)

Image 8
Contents Parts List NO. B2871300404 S/N 3798495~ Model DCA-36SPXProposition 65WARNING Diesel engine exhaust and someDCA-36SPX- Operation and Parts Manual REV. #1 04/14/10 Table of Contents Parts Ordering Procedures Ordering parts has never been easierDCA-36SPX Specifications DCA-36SPX Dimensions TOP, Side and Front DimensionsDCA-36SPX Safety Message Alert Symbols Hazard SymbolsDCA-36SPX Safety Message Alert Symbols General Safety DCA-36SPX Rules for Safe OperationInjury People Carbon monoxide gasMaintenance Safety DCA-36SPX Rules for Safe OperationBattery Safety DCA-36SPX Rules for Safe OperationDeath Towing and Transporting Safety Guidelines section in this manualDCA-36SPX- Operation and Parts Manual REV. #1 04/14/10 DCA-36SPX Generator Decals Generator DecalsDCA-36SPX Generator Decals Generator Decals Cont inuedDCA-36SPX Installation Typical Generator Grounding ApplicationOutdoor Installation Indoor InstallationWhen connecting the generator MountingGenerator Engine Operating PanelGenerator Control Panel Output Terminal PanelDCA-36SPX Major Components Item no Description22 DCA-36SPX- Operation and Parts Manual REV. #1 04/14/10 DCA-36SPX Generator Control Panel DCA-36SPX Engine Operating Panel DCA-36SPX Engine Operating Panel Auto On/Off Engine Controller MpecDCA-36SPX Output Terminal Panel Familiarization Output Terminal FamiliarizationDCA-36SPX Output Terminal Panel Familiarization 100VAC Gfci ReceptaclesConnecting Loads Over Current RelaySingle Phase Load DCA-36SPX Load APPLICATION/MAXIMUM AmperageMotors and motor-driven Generator AmperageDCA-36SPX Gauge READING/TERMINAL Panel Connections DCA-36SPX Setup Circuit BreakersLubrication Oil Fuel CheckRefueling Procedure RefuelingCleaning the Radiator Air Cleaner Fan Belt TensionCoolant Antifreeze/Summer Coolant/Water Operation FreezingWeatherBattery Battery Cable InstallationWiring AlternatorClose all engine enclosure doors Figure DCA-36SPX Generator START-UP Procedure ManualBefore Starting Voltmeter On position FigureStarting Auto Mode Place the Mpec Control Switch in the Auto positionEmergency Shutdown Procedure DCA-36SPX Generator SHUT-DOWN ProceduresNormal Shutdown Procedure DCA-36SPX Maintenance Cleaning the Fuel Strainer Air RemovalCheck Oil Level Replacing Oil FilterBattery Charger JacketWater Heater Power Connections To ensure adequate startingDCA-36SPX -TRAILER Maintenance Trailer MaintenanceDCA-36SPX -TRAILER Maintenance Brake AdjustmentBrakes Check the wheel and drum for free rotationSuspension Tires/Wheels/Lug NutsTireWear/Inflation Lug Nut Torque Requirements Start all wheel lug nuts by handDCA-36SPX -TRAILERWIRING Diagram DCA-36SPX Generatorwiring Diagram Generator Wiring DiagramDCA-36SPX Enginewiring Diagram DCA-36SPX -TROUBLESHOOTING Engine Engine TroubleshootingDCA-36SPX -TROUBLESHOOTING Engine DCA-36SPX -TROUBLESHOOTING Generator Generator TroubleshootingDCA-36SPX -TROUBLESHOOTING Engine Controller Engine Controller Troubleshooting MpecDCA-36SPX- Operation and Parts Manual REV. #1 04/14/10 DCA-36SPX Explanation of Code in Remarks Column QTY. ColumnDescription Part number on this Suggested Spare Parts listDCA-36SPX Suggested Spare Parts DCA-36SPX Generator Assy B2110100702 80510700030012110035 0042510000DCA-36SPX- Engine Operating Panel Assy 0602202545 06018313400602120095 0602122093DCA-36SPX- Control BOX Assy Control BOX ASSY. S/N 7800001~7800129B2214001202 06018704340601870490 0021004040DCA-36SPX- Engine and Radiator Assy M1923200054 89416184108970497081 0605000048Engine & Radiator Assy 0802081104 0199100215M1317100004 0199100800DCA-36SPX- Outputterminal Assy B2231700303 08403129040801830704 0039312000DCA-36SPX- Battery Assy 0602220187 B9310500004M9103000304 0602220920DCA-36SPX- Muffler Assy B3923200044 0016910025M1333002503 8943690210DCA-36SPX- Fueltank Assy M1363001602 0605505070M1363200104 0805003414DCA-36SPX- Enclosure Assy M1413002902 M1413400004M1423001902 M1493106713DCA-36SPX- Enclosure ASSY. 0019108055 34A 004230800034B 0042408000 M1453003403DCA-36SPX- Rubber Seals Assy 0228901350 02292006600228900610 0228900970DCA-36SPX- Nameplate and Decals Assy B2551000403 B25100040M1550001304 M1500013082 DCA-36SPX- Operation and Parts Manual REV. #1 04/14/10 DCA-36SPX- Operation and Parts Manual REV. #1 04/14/10 HERE’S HOW to GET Help