Manuals / Bunn / Kitchen Appliance / Beverage Dispenser

Bunn service manual USER NOTICES Cont, 00831.0000, 28368.0000, FMD-428964.0004 FMD-528964.0003

Models: FMD-4 FMD-5

1 45

Download 45 pages 45.11 Kb

Page 3

Image 3

USER NOTICES (Cont.)

00831.0000

00656.0000

28368.0000

FMD-4 28964.0004

FMD-5 28964.0003

3	35135 012103

Page 3

Image 3

Bunn service manual USER NOTICES Cont, 00831.0000, 28368.0000, FMD-428964.0004 FMD-528964.0003

Contents

BUNN-O-MATICCORPORATION POST OFFICE BOX SPRINGFIELD, ILLINOISPHONE 217 529-6601FAX BUNN FMD-4 FMD-5FMD-428328.0008 BUNN-O-MATICCOMMERCIAL PRODUCT WARRANTYINTRODUCTION USER NOTICESFMD-428964.0004 FMD-528964.0003 USER NOTICES Cont00831.0000 28368.0000PLUMBING REQUIREMENTS INITIAL SET-UPELECTRICAL REQUIREMENTS ELECTRICAL HOOK-UPRUNNING A RINSE SEQUENCE RINSE TIMERSINITIAL FILL & HEAT LIQUID LEVEL CONTROLHOPPER MOTOR SPEED PROGRAMING CLEANINGADJUSTMENTS COLD BEVERAGE SET-UPOPTIONALDRAINING THE HOT WATER TANK REMEDY TROUBLESHOOTINGPROBLEM PROBABLE CAUSEREMEDY TROUBLESHOOTING contPROBLEM PROBABLE CAUSEWater is not hot Cont TROUBLESHOOTING contPROBLEM PROBABLE CAUSEREMEDY PROBLEMPROBABLE CAUSE Product overflows containerTROUBLESHOOTING CONT PROBLEM PROBABLE CAUSEREMEDY AUGER DRIVE COMPONENTS FMD-4 SERVICECOMPONENT ACCESS ContentsSERVICE AUGER DRIVE COMPONENTS - FMD-4CONTAUGER DRIVE COMPONENTS - FMD-4cont SERVICE contSERVICE cont AUGER DRIVE COMPONENTS - FMD-4& FMD-5contSERVICE cont AUGER DRIVE COMPONENTS - FMD-4& FMD-5contAuger Drive Motor Refer to Fig SERVICE cont BALLASTS - FMD-4& FMD-5FIG. 9 CONTROL THERMOSTAT LocationSERVICE cont SERVICE cont CONTROL BOARDSERVICE cont CONTROL BOARD CONT1.Disconnect the dispenser from the power source FMD-5 DISPENSE SWITCHS - FMD-4& FMD-5FIG.13 DISPENSE SWITCHES FMD-4SERVICE cont DISPENSE SWITCHES contSERVICE cont SERVICE cont FROTHER AND WHIPPER MOTOR - FMD-4shown & FMD-512.Slide the slinger 9 off of the motor shaft SERVICE contSERVICE cont INCREASE/DECREASE SWITCHSERVICE cont LAMP REPLACEMENT Refer to FigLAMP HOLDERS FIG. 22 LAMP HOLDERSLAMP REPLACEMENT Refer to Fig.22cont LAMP STARTER and SOCKET Refer to Fig. 22 LocationSERVICE cont SERVICE cont LIMIT THERMOSTATSERVICE cont RINSE/RUN SWITCHSERVICE cont HOT/COLD SWITCH OptionalSERVICE cont SOLENOID VALVE COLD WATER - OPTIONALLocation SERVICE contSERVICE cont SOLENOID VALVE DISPENSE - FMD-4& FMD-5contSERVICE cont SOLENOID VALVE INLETSERVICE cont TANK HEATERSERVICE cont TANK HEATER SWITCHSERVICE cont TANK HEATER RELAY 120V Dispensers onlySERVICE cont TRANSFORMER120 VOLTS AC - 2 WIRE SINGLE PHASE, 60HZ SCHEMATIC WIRING DIAGRAM FMD-4120/208-240VOLTS AC - 3 WIRE SINGLE PHASE, 60HZ SCHEMATIC WIRING DIAGRAM FMD-4SCHEMATIC WIRING DIAGRAM FMD-5 SINGLE PHASE, 60HZ120 VOLTS AC - 2 WIRE SCHEMATIC WIRING DIAGRAM FMD-5 120/208-240VOLTS AC - 3 WIRESINGLE PHASE, 60HZ