Manuals / Cornelius / Kitchen Appliance / Beverage Dispenser

Cornelius QUANTUM SERIES service manual IMI Cornelius Inc One Cornelius Place Anoka, MN U.S.A

Models: QUANTUM SERIES

1 37

Download 37 pages 15.63 Kb

Page 21

Image 21

IMI Cornelius Inc.

One Cornelius Place

Anoka, MN 55303-1592

U.S.A.

Total Systems Commitment

Page 21

Image 21

Cornelius QUANTUM SERIES service manual IMI Cornelius Inc One Cornelius Place Anoka, MN U.S.A, Total Systems Commitment

Contents

QUANTUM SERIES IMI CORNELIUS INCPart Number Revision B - November UNIT SPECIFICATIONS TABLE OF CONTENTSPREINSTALLATION installation specificationsUNIT SPECIFICATIONS RECEIVING PREINSTALLATIONUNPACKING COUNTER LOCATIONCONNECTING WATER SUPPLY INSTALLATION SPECIFICATIONSWATER SUPPLY ELECTRICALCANCEL/POUR BUTTON FLUSHING AND SANITIZING ON START UPPROGRAMMING PORTION CONTROL OPTIONAL BRIX SETTING CONCENTRATE LOADING AND BRIXINGPLACING CONCENTRATE PRODUCTS ON DISPENSING PLATFORM CHANGING CONCENTRATE FLAVORDAILY SYSTEM FLUSH PROCEDURE CLEANING AND SANITIZING PROCEDURESWEEKLY SANITIZING PROCEDURE DAILY PART WASHINGSEMI-ANNUAL GENERAL CLEANING WEEKLY CHECK BRIX SETTINGNOTE If brix problem persists, refer to trouble shooting guide YEARLY REPLACE PUMP TUBINGReplacement of Pump Hose see figure 720901120 720901120 PROBLEM TROUBLE-SHOOTING GUIDEPROBABLE CAUSE REMEDYRelay or compressor is defective. Test and replace faulty item Compressor starts but does not switch off of start windingRepair leak. Evacuate and recharge system Restore water Reconnect Disassemble and clean solenoid. Replace if necessaryService switch located under drip tray in OFF position Quantum Series Installation and Service ManualDoor switch open 6.25 amp Fuse inside front electrical box blown Turn on switchRefer to Concentrate Loading sec- tion of this manual Quantum Series Installation and Service ManualRefer to Concentrate Loading sec- tion of this manual Refer to Concentrate Loading sec- tion of this manualRun/Flush switch on pump platform in Run mode Water continuously drips from nozzle when in OFF mode No Flush Cyclewhen the dispenser utilizes water from a pre-cooler Clean condenser coil Replace condenser fan motor Replace thermostatNo power to transformer or no 28VAC output from transformer Concentrate warm, water cold con’t Brix Problem Pump InoperativeClean and/or replace parts as nec- essary Loss of refrigerant charge due to leak in systemRelay on voltage regulator board VRB stuck on Portion control pad stuck in on positionHigh Brix readings result in Check the dispenser cabinet tem- perature is at 34×F - 40×F1.1- 4.5×C720901120 Adjust SwitchTotal Systems Commitment IMI Cornelius Inc One Cornelius Place Anoka, MN U.S.AQUANTUM SERIES JUICE DISPENSER MODEL NO ILLUSTRATED PARTS LISTILLUSTRATED PARTS LIST QUANTUM SERIES JUICE DISPENSERFIGURE 1. GENERAL ASSEMBLY IMI CORNELIUS INC One Cornelius Place Anoka, MN Telephone FacsimileQUANTUM SERIES JUICE DISPENSER ILLUSTRATED PARTS LISTFIGURE 2. REFRIGERATION AND FRAME ASSEMBLY ILLUSTRATED PARTS LISTQUANTUM SERIES JUICE DISPENSER IMI CORNELIUS INC One Cornelius Place Anoka, MN Telephone FacsimileILLUSTRATED PARTS LIST QUANTUM SERIES JUICE DISPENSER SEE FIGUREFIGURE 3. UPPER CABINET ASSEMBLY ILLUSTRATED PARTS LISTQUANTUM SERIES JUICE DISPENSER IMI CORNELIUS INC One Cornelius Place Anoka, MN Telephone FacsimileQUANTUM SERIES JUICE DISPENSER SEE FIGURE ILLUSTRATED PARTS LISTFIGURE 4. PLATFORM ASSEMBLY ILLUSTRATED PARTS LISTQUANTUM SERIES JUICE DISPENSER 8 of Rev AQUANTUM SERIES JUICE DISPENSER SEE FIGURE ILLUSTRATED PARTS LISTQUANTUM SERIES JUICE DISPENSER ILLUSTRATED PARTS LISTQUANTUM SERIES JUICE DISPENSER ILLUSTRATED PARTS LISTILLUSTRATED PARTS LIST QUANTUM SERIES JUICE DISPENSER12 of 16 Rev A ILLUSTRATED PARTS LIST QUANTUM SERIES JUICE DISPENSERCover Asy Merchandsr Push Button QUANTUM SERIES JUICE DISPENSER ILLUSTRATED PARTS LISTQUANTUM SERIES JUICE DISPENSER ILLUSTRATED PARTS LISTILLUSTRATED PARTS LIST QUANTUM SERIES JUICE DISPENSERBrkt Voltage Regulator 3000 Series