Manuals / Cornelius / Kitchen Appliance / Beverage Dispenser

Cornelius QUANTUM SERIES Quantum Series Juice Dispenser See Figure, Illustrated Parts List

Models: QUANTUM SERIES

1 37

Download 37 pages 15.63 Kb

Page 28

Manual background

IMI CORNELIUS INC.

One Cornelius Place

Anoka, MN. 55303–6234

Telephone 1-800-238-3600

Facsimile 1-800-258-0255

www.cornelius.com

ILLUSTRATED PARTS LIST

QUANTUM SERIES JUICE DISPENSER

(SEE FIGURE 3)

Item
No.	Part No.	Name

		Upper Cabinet Asy

1	45051	Stud Latch No. 10-32

2	45119	Gasket Liner (1000 and 2000
		Series)
	45662	Gasket Liner (3000 Series)
	45419	Gasket Liner (4000 Series)

3	45141	Wrap Front (1000 and 2000 Series)
	45657	Wrap Front (3000 Series)
	45441	Wrap Front (4000 Series)

4	45142	Panel Botm Front (1000 Series)
	45207	Panel Botm Front (2000 Series)
	45664	Panel Botm Front (3000 Series)
	45407	Panel Botm Front (4000 Series)

5	45167	Liner Inner Asy (1000 Series)
	45220	Liner Inner Asy (2000 Series)
	45654100	Liner Inner Asy (3000 Series)
	45420100	Liner Inner Asy (4000 Series)

Item
No.	Part No.	Name

6	45027001	Bushing

7	11761	Harn Door (1000 Series: Not
		Shown)
	11762	Harn Door (2000 Series: Not
		Shown)
	11763	Harn Door (3000 Series: Not
		Shown)
	11823	Harn Door (4000 Series: Not
		Shown)

8	0704105	Screw No. 8-32 x 1/2” THMS

9	0704101	Screw MA No. 8-32 TRPH 12

10	04441	Spacer Lower

11	0702609	Screw MA No. 8-32 BDPH 24

12	46366	Bushing Hinge

13	45132	Brkt Conn Platform (1000 Series)
	45232	Brkt Conn Platform (2000 and 4000
		Series)
	45632	Brkt Conn Platform (3000 Series)

14	0704001	Screw No. 8 x 3/8”

15	47121004	Magnet Door Seal

16	47121005	Magnet Door Seal (1000 and 2000
		Series)
	47121006	Magnet Door Seal (3000 Series)

QUANTUM SERIES

7 of 16	Manual Part No. 720901120IPL
7 of 16	4-25-2001 Rev: 12-3-01
Rev A	 IMI Cornelius Co., 2001

Image 28

Cornelius QUANTUM SERIES service manual Quantum Series Juice Dispenser See Figure, Illustrated Parts List

Contents

IMI CORNELIUS INC QUANTUM SERIESPart Number Revision B - November TABLE OF CONTENTS UNIT SPECIFICATIONSPREINSTALLATION installation specificationsUNIT SPECIFICATIONS PREINSTALLATION RECEIVINGUNPACKING COUNTER LOCATIONINSTALLATION SPECIFICATIONS CONNECTING WATER SUPPLYWATER SUPPLY ELECTRICALFLUSHING AND SANITIZING ON START UP CANCEL/POUR BUTTONPROGRAMMING PORTION CONTROL OPTIONAL CONCENTRATE LOADING AND BRIXING BRIX SETTINGPLACING CONCENTRATE PRODUCTS ON DISPENSING PLATFORM CHANGING CONCENTRATE FLAVORCLEANING AND SANITIZING PROCEDURES DAILY SYSTEM FLUSH PROCEDUREWEEKLY SANITIZING PROCEDURE DAILY PART WASHINGWEEKLY CHECK BRIX SETTING SEMI-ANNUAL GENERAL CLEANINGNOTE If brix problem persists, refer to trouble shooting guide YEARLY REPLACE PUMP TUBINGReplacement of Pump Hose see figure 720901120 720901120 TROUBLE-SHOOTING GUIDE PROBLEMPROBABLE CAUSE REMEDYCompressor starts but does not switch off of start winding Relay or compressor is defective. Test and replace faulty itemRepair leak. Evacuate and recharge system Restore water Reconnect Disassemble and clean solenoid. Replace if necessaryQuantum Series Installation and Service Manual Service switch located under drip tray in OFF positionDoor switch open 6.25 amp Fuse inside front electrical box blown Turn on switchQuantum Series Installation and Service Manual Refer to Concentrate Loading sec- tion of this manualRefer to Concentrate Loading sec- tion of this manual Refer to Concentrate Loading sec- tion of this manualWater continuously drips from nozzle when in OFF mode No Flush Cycle Run/Flush switch on pump platform in Run modewhen the dispenser utilizes water from a pre-cooler Clean condenser coil Replace condenser fan motor Replace thermostatConcentrate warm, water cold con’t Brix Problem Pump Inoperative No power to transformer or no 28VAC output from transformerClean and/or replace parts as nec- essary Loss of refrigerant charge due to leak in systemPortion control pad stuck in on position Relay on voltage regulator board VRB stuck onHigh Brix readings result in Check the dispenser cabinet tem- perature is at 34×F - 40×F1.1- 4.5×CAdjust Switch 720901120IMI Cornelius Inc One Cornelius Place Anoka, MN U.S.A Total Systems CommitmentILLUSTRATED PARTS LIST QUANTUM SERIES JUICE DISPENSER MODEL NOQUANTUM SERIES JUICE DISPENSER ILLUSTRATED PARTS LISTFIGURE 1. GENERAL ASSEMBLY IMI CORNELIUS INC One Cornelius Place Anoka, MN Telephone FacsimileILLUSTRATED PARTS LIST QUANTUM SERIES JUICE DISPENSERILLUSTRATED PARTS LIST FIGURE 2. REFRIGERATION AND FRAME ASSEMBLYQUANTUM SERIES JUICE DISPENSER IMI CORNELIUS INC One Cornelius Place Anoka, MN Telephone FacsimileQUANTUM SERIES JUICE DISPENSER SEE FIGURE ILLUSTRATED PARTS LISTILLUSTRATED PARTS LIST FIGURE 3. UPPER CABINET ASSEMBLYQUANTUM SERIES JUICE DISPENSER IMI CORNELIUS INC One Cornelius Place Anoka, MN Telephone FacsimileILLUSTRATED PARTS LIST QUANTUM SERIES JUICE DISPENSER SEE FIGUREILLUSTRATED PARTS LIST FIGURE 4. PLATFORM ASSEMBLYQUANTUM SERIES JUICE DISPENSER 8 of Rev AILLUSTRATED PARTS LIST QUANTUM SERIES JUICE DISPENSER SEE FIGUREILLUSTRATED PARTS LIST QUANTUM SERIES JUICE DISPENSERILLUSTRATED PARTS LIST QUANTUM SERIES JUICE DISPENSERQUANTUM SERIES JUICE DISPENSER ILLUSTRATED PARTS LIST12 of 16 Rev A QUANTUM SERIES JUICE DISPENSER ILLUSTRATED PARTS LISTCover Asy Merchandsr Push Button ILLUSTRATED PARTS LIST QUANTUM SERIES JUICE DISPENSERILLUSTRATED PARTS LIST QUANTUM SERIES JUICE DISPENSERQUANTUM SERIES JUICE DISPENSER ILLUSTRATED PARTS LISTBrkt Voltage Regulator 3000 Series