Manuals / Cornelius / Kitchen Appliance / Beverage Dispenser

Cornelius QUANTUM SERIES service manual Preinstallation, Receiving, Unpacking, Counter Location

Models: QUANTUM SERIES

1 37

Download 37 pages 15.63 Kb

Page 4

Quantum Series Installation and Service Manual

PREINSTALLATION

RECEIVING

Each unit is completely tested and inspected before shipment. At time of shipment, the carrier accepts the unit and any claim for damage must be made with the carrier.

Upon receiving from the carrier, please, inspect the carton for visible damage. If damage exists, have the carrier make a note on the bill of lading and file a claim with the carrier.

UNPACKING

•Remove staples securing carton to pallet.

•Lift carton up and off of unit.

•Remove top insert and shipping bag.

•Open the upper cabinet door and remove installation kit.

•Remove bolts securing unit to pallet.

•Lift unit off of pallet.

•Open the package, take legs and secure them to the bottom of the unit.

NOTE: Do not lay the unit on sides or on the back.

•Tilt the unit only when securing legs.

•If the unit is to be transported from the place where it was unpacked, do not remove the unit from the pallet. Transport it on the pallet to the installation site.

COUNTER LOCATION

•Select location in well ventilated area, close to grounded electrical outlet. If possible do not place the unit close to hot and/or steaming machines.

720901120

- 2 -

Image 4

Cornelius QUANTUM SERIES service manual Preinstallation, Receiving, Unpacking, Counter Location

Contents

IMI CORNELIUS INC QUANTUM SERIESPart Number Revision B - November TABLE OF CONTENTS UNIT SPECIFICATIONSPREINSTALLATION installation specificationsUNIT SPECIFICATIONS PREINSTALLATION RECEIVINGUNPACKING COUNTER LOCATIONINSTALLATION SPECIFICATIONS CONNECTING WATER SUPPLYWATER SUPPLY ELECTRICALFLUSHING AND SANITIZING ON START UP CANCEL/POUR BUTTONPROGRAMMING PORTION CONTROL OPTIONAL CONCENTRATE LOADING AND BRIXING BRIX SETTINGPLACING CONCENTRATE PRODUCTS ON DISPENSING PLATFORM CHANGING CONCENTRATE FLAVORCLEANING AND SANITIZING PROCEDURES DAILY SYSTEM FLUSH PROCEDUREWEEKLY SANITIZING PROCEDURE DAILY PART WASHINGWEEKLY CHECK BRIX SETTING SEMI-ANNUAL GENERAL CLEANINGNOTE If brix problem persists, refer to trouble shooting guide YEARLY REPLACE PUMP TUBINGReplacement of Pump Hose see figure 720901120 720901120 TROUBLE-SHOOTING GUIDE PROBLEMPROBABLE CAUSE REMEDYCompressor starts but does not switch off of start winding Relay or compressor is defective. Test and replace faulty itemRepair leak. Evacuate and recharge system Restore water Reconnect Disassemble and clean solenoid. Replace if necessaryQuantum Series Installation and Service Manual Service switch located under drip tray in OFF positionDoor switch open 6.25 amp Fuse inside front electrical box blown Turn on switchQuantum Series Installation and Service Manual Refer to Concentrate Loading sec- tion of this manualRefer to Concentrate Loading sec- tion of this manual Refer to Concentrate Loading sec- tion of this manualWater continuously drips from nozzle when in OFF mode No Flush Cycle Run/Flush switch on pump platform in Run modewhen the dispenser utilizes water from a pre-cooler Clean condenser coil Replace condenser fan motor Replace thermostatConcentrate warm, water cold con’t Brix Problem Pump Inoperative No power to transformer or no 28VAC output from transformerClean and/or replace parts as nec- essary Loss of refrigerant charge due to leak in systemPortion control pad stuck in on position Relay on voltage regulator board VRB stuck onHigh Brix readings result in Check the dispenser cabinet tem- perature is at 34×F - 40×F1.1- 4.5×CAdjust Switch 720901120IMI Cornelius Inc One Cornelius Place Anoka, MN U.S.A Total Systems CommitmentILLUSTRATED PARTS LIST QUANTUM SERIES JUICE DISPENSER MODEL NOQUANTUM SERIES JUICE DISPENSER ILLUSTRATED PARTS LISTFIGURE 1. GENERAL ASSEMBLY IMI CORNELIUS INC One Cornelius Place Anoka, MN Telephone FacsimileILLUSTRATED PARTS LIST QUANTUM SERIES JUICE DISPENSERILLUSTRATED PARTS LIST FIGURE 2. REFRIGERATION AND FRAME ASSEMBLYQUANTUM SERIES JUICE DISPENSER IMI CORNELIUS INC One Cornelius Place Anoka, MN Telephone FacsimileQUANTUM SERIES JUICE DISPENSER SEE FIGURE ILLUSTRATED PARTS LISTILLUSTRATED PARTS LIST FIGURE 3. UPPER CABINET ASSEMBLYQUANTUM SERIES JUICE DISPENSER IMI CORNELIUS INC One Cornelius Place Anoka, MN Telephone FacsimileILLUSTRATED PARTS LIST QUANTUM SERIES JUICE DISPENSER SEE FIGUREILLUSTRATED PARTS LIST FIGURE 4. PLATFORM ASSEMBLYQUANTUM SERIES JUICE DISPENSER 8 of Rev AILLUSTRATED PARTS LIST QUANTUM SERIES JUICE DISPENSER SEE FIGUREILLUSTRATED PARTS LIST QUANTUM SERIES JUICE DISPENSERILLUSTRATED PARTS LIST QUANTUM SERIES JUICE DISPENSERQUANTUM SERIES JUICE DISPENSER ILLUSTRATED PARTS LIST12 of 16 Rev A QUANTUM SERIES JUICE DISPENSER ILLUSTRATED PARTS LISTCover Asy Merchandsr Push Button ILLUSTRATED PARTS LIST QUANTUM SERIES JUICE DISPENSERILLUSTRATED PARTS LIST QUANTUM SERIES JUICE DISPENSERQUANTUM SERIES JUICE DISPENSER ILLUSTRATED PARTS LISTBrkt Voltage Regulator 3000 Series