Manuals / Cornelius / Kitchen Appliance / Beverage Dispenser

Cornelius QUANTUM SERIES Quantum Series Juice Dispenser Model No, Illustrated Parts List

Models: QUANTUM SERIES

1 37

Download 37 pages 15.63 Kb

Page 22

Image 22

IMI CORNELIUS INC.

One Cornelius Place

Anoka, MN. 55303–6234

Telephone 1-800-238-3600

Facsimile 1-800-258-0255

www.cornelius.com

ILLUSTRATED PARTS LIST

QUANTUM SERIES JUICE DISPENSER

MODEL NO.

45200001

45200002

45200003

45200004

45200101

45200102

45200103

45200104

45400001

45400002

45400101

45400102

45400103

45400104

45500001

45500002

45500101

45500102

45650001

45650003

45650101

45650103

45650104

45650105

QUANTUM SERIES

1 of 16	Manual Part No. 720901120IPL
1 of 16	4-25-2001 Rev: 12-3-01
Rev A	 IMI Cornelius Co., 2001

Page 22

Image 22

Cornelius QUANTUM SERIES service manual Quantum Series Juice Dispenser Model No, Illustrated Parts List

Contents

IMI CORNELIUS INC QUANTUM SERIESPart Number Revision B - November PREINSTALLATION TABLE OF CONTENTSUNIT SPECIFICATIONS installation specificationsUNIT SPECIFICATIONS UNPACKING PREINSTALLATIONRECEIVING COUNTER LOCATIONWATER SUPPLY INSTALLATION SPECIFICATIONSCONNECTING WATER SUPPLY ELECTRICALFLUSHING AND SANITIZING ON START UP CANCEL/POUR BUTTONPROGRAMMING PORTION CONTROL OPTIONAL PLACING CONCENTRATE PRODUCTS ON DISPENSING PLATFORM CONCENTRATE LOADING AND BRIXINGBRIX SETTING CHANGING CONCENTRATE FLAVORWEEKLY SANITIZING PROCEDURE CLEANING AND SANITIZING PROCEDURESDAILY SYSTEM FLUSH PROCEDURE DAILY PART WASHINGNOTE If brix problem persists, refer to trouble shooting guide WEEKLY CHECK BRIX SETTINGSEMI-ANNUAL GENERAL CLEANING YEARLY REPLACE PUMP TUBINGReplacement of Pump Hose see figure 720901120 720901120 PROBABLE CAUSE TROUBLE-SHOOTING GUIDEPROBLEM REMEDYRepair leak. Evacuate and recharge system Restore water Reconnect Compressor starts but does not switch off of start windingRelay or compressor is defective. Test and replace faulty item Disassemble and clean solenoid. Replace if necessaryDoor switch open 6.25 amp Fuse inside front electrical box blown Quantum Series Installation and Service ManualService switch located under drip tray in OFF position Turn on switchRefer to Concentrate Loading sec- tion of this manual Quantum Series Installation and Service ManualRefer to Concentrate Loading sec- tion of this manual Refer to Concentrate Loading sec- tion of this manualwhen the dispenser utilizes water from a pre-cooler Water continuously drips from nozzle when in OFF mode No Flush CycleRun/Flush switch on pump platform in Run mode Clean condenser coil Replace condenser fan motor Replace thermostatClean and/or replace parts as nec- essary Concentrate warm, water cold con’t Brix Problem Pump InoperativeNo power to transformer or no 28VAC output from transformer Loss of refrigerant charge due to leak in systemHigh Brix readings result in Portion control pad stuck in on positionRelay on voltage regulator board VRB stuck on Check the dispenser cabinet tem- perature is at 34×F - 40×F1.1- 4.5×CAdjust Switch 720901120IMI Cornelius Inc One Cornelius Place Anoka, MN U.S.A Total Systems CommitmentILLUSTRATED PARTS LIST QUANTUM SERIES JUICE DISPENSER MODEL NOFIGURE 1. GENERAL ASSEMBLY QUANTUM SERIES JUICE DISPENSERILLUSTRATED PARTS LIST IMI CORNELIUS INC One Cornelius Place Anoka, MN Telephone FacsimileILLUSTRATED PARTS LIST QUANTUM SERIES JUICE DISPENSERQUANTUM SERIES JUICE DISPENSER ILLUSTRATED PARTS LISTFIGURE 2. REFRIGERATION AND FRAME ASSEMBLY IMI CORNELIUS INC One Cornelius Place Anoka, MN Telephone FacsimileQUANTUM SERIES JUICE DISPENSER SEE FIGURE ILLUSTRATED PARTS LISTQUANTUM SERIES JUICE DISPENSER ILLUSTRATED PARTS LISTFIGURE 3. UPPER CABINET ASSEMBLY IMI CORNELIUS INC One Cornelius Place Anoka, MN Telephone FacsimileILLUSTRATED PARTS LIST QUANTUM SERIES JUICE DISPENSER SEE FIGUREQUANTUM SERIES JUICE DISPENSER ILLUSTRATED PARTS LISTFIGURE 4. PLATFORM ASSEMBLY 8 of Rev AILLUSTRATED PARTS LIST QUANTUM SERIES JUICE DISPENSER SEE FIGUREILLUSTRATED PARTS LIST QUANTUM SERIES JUICE DISPENSERILLUSTRATED PARTS LIST QUANTUM SERIES JUICE DISPENSERQUANTUM SERIES JUICE DISPENSER ILLUSTRATED PARTS LIST12 of 16 Rev A QUANTUM SERIES JUICE DISPENSER ILLUSTRATED PARTS LISTCover Asy Merchandsr Push Button ILLUSTRATED PARTS LIST QUANTUM SERIES JUICE DISPENSERILLUSTRATED PARTS LIST QUANTUM SERIES JUICE DISPENSERQUANTUM SERIES JUICE DISPENSER ILLUSTRATED PARTS LISTBrkt Voltage Regulator 3000 Series