Table of Contents | 3 |
Introduction |
|
Introduction | 2 |
Important Information | 2 |
Safety Precautions |
|
Safety Precautions | 4 |
Specifications |
|
Heating Specifications | 6 |
Dimensions | 6 |
Electrical Specifications | 6 |
Fuel | 6 |
EPA Compliance | 6 |
Installation |
|
Before You Begin | 7 |
Packing List | 7 |
Installation Options | 7 |
Planning The Installation | 7 |
Stove Placement | 7 |
Floor Protection Requirements | 7 |
Clearances - Straight Installation | 8 |
Clearances - Corner Installation | 8 |
Venting the Pellet Stove | 9 |
Maximum Venting Distance | 9 |
Pellet Vent Type | 10 |
Installing the Pellet Vent | 10 |
Pellet Vent Termination | 10 |
Mobile Home Requirements | 11 |
Outside Air (used for combustion) | 11 |
Alcove Installation Requirements | 12 |
Baffle Installation | 12 |
Door Seal Verification | 12 |
Restrictor Adjustment | 12 |
Thermostat Installation | 13 |
Installation Example: Direct |
|
Installation | 14 |
Installation Example: Interior Vertical Installation .... | 15 |
Installation Example: Class A Chimney Retrofit | 16 |
InstallationExample:MasonryFireplaceHearthStove | 17 |
InstallationExample:FreestandingMasonryChimney | 19 |
Operation |
|
Safety Notice | 20 |
Location of Controls | 20 |
Starting the Heater for the First Time | 20 |
Loading Pellets | 21 |
The Two Modes of Operation | 21 |
Operation (continued) |
| |
Manual Mode | 22 | |
Auto Mode | 23 | |
Restrictor Adjustment | 24 | |
Adjusting the Fan Speed | 24 | |
25 | ||
"MANUAL AUGER" Button | 25 | |
"AUGER ON" Light | 25 | |
"FAULT" Light | 25 | |
Fault Codes (for qualified service personnel only) | 25 | |
Power Outages | 25 | |
Using a Pellet/Corn Mix with This Heater | 26 | |
Maintenance |
| |
Daily Maintenance (whenever using the stove) | 27 | |
Inspect the Burn | 27 | |
Make Sure Pellets are Not Piling Up | 27 | |
Check Firepot for Clinkers | 28 | |
Cleaning the Firepot | 28 | |
Door Opening | 29 | |
Flyash Removal | 30 | |
Clean the Hopper | 30 | |
Clean the Heat Exchange Tubes | 30 | |
Clean the Baffles | 31 | |
Sweep Ash Into Ashpan | 32 | |
Check Ashpan, Dispose if necessary | 33 | |
Clean the Glass | 33 | |
Yearly Maintenance (or every two tons) | 34 | |
Clean the Vertical Exhaust Duct | 34 | |
Clean the Exhaust Blower | 36 | |
Clean the Convection Blower | 37 | |
Clean the Vent | 37 | |
Adjusting the Door Hinge and Latch | 37 | |
Check for Air Leaks Around the Door, Glass, and |
| |
Ashpan | 37 | |
Replacement Parts | 38 | |
Normal | Operating Sounds |
|
Normal Operating Sounds | 39 | |
Safety | Label |
|
Safety Label | 40 | |
Warranty |
| |
Warranty | 41 | |
Index |
|
|
Index | 42 | |
Travis Industries | 4061016 | 1 0 0 - 0 1 1 8 4 |
