RDV4136 Series Direct Vent Gas Fireplace
Lighting & Operating Instructions
For Fireplaces equipped with AF4000 Gas Valve
Warning:
For Your Safety, Read the Following Warnings
before Lighting the Appliance
A.This fireplace is equipped with an ignition device which automatically lights the pilot. DO NOT try to light the pilot by hand.
B.BEFORE OPERATING, smell all around the appliance area for gas. Be sure to smell next to the floor because some gas is heavier than the air and will settle on the floor.
What to do if you smell gas
•Do not try to light any appliance.
•Do not operate any electrical switch.
•Do not use any phone in your building.
•Immediately call your gas supplier from a neighbor’s phone. Follow the gas suppliers instructions.
•If you cannot contact your gas supplier call the Fire Department
C.Do not use this appliance if any part has been under water. Immediately call a qualified service technician to inspect the appliance and replace any part of the control system and any gas control that has been under water.
Lighting Instructions
1. | STOP! Read the safety information above before |
|
|
| Spark to Pilot | |
| continuing. |
|
|
|
| Pilot Assembly |
|
|
|
|
|
| |
2. | This appliance is equipped with an ignition device | “S” Connection |
|
| ||
| which automatically lights the pilot. DO NOT try to |
|
| |||
| Connect to Module |
| ||||
| light the pilot by hand. |
|
| |||
|
|
|
|
|
| |
3. | Access the gas control by removing the side cover | Pilot Adjustment |
|
| ||
| access door on the left side of the unit. |
|
|
| ||
4. | Turn the remote switch, if used, OFF. Turn the |
| Screw |
| Pilot Gas Connection | |
Inlet Pressure |
| |||||
| wireless remote, if used, OFF. |
| Side or Back | |||
| Tap |
|
| |||
|
|
|
| “I” Connection | ||
5. | Wait five (5) minutes to clear out any gas. |
|
|
|
| Connect to |
| Then smell for gas, including near the floor. |
|
|
|
| Module |
|
|
|
|
|
| |
| If you smell gas, STOP. Follow instruction B |
|
|
|
|
|
| in the safety warnings above. If you do not |
|
|
|
|
|
| smell gas, go on to the next step. |
|
|
|
|
|
6. | Close the access door. |
|
|
|
|
|
7. | If the appliance will not operate, follow the |
|
|
|
|
|
| instructions TURNING OFF THE GAS TO |
|
|
|
|
|
| THE APPLIANCE, and call your service |
| Pilot Internal |
|
| Main Valve Internal Solenoid |
| technician or gas supplier. |
| Outlet |
| ||
|
| Solenoid |
| Connection | ||
|
|
| Pressure Tap | |||
|
|
| Connection | Green & White Wires | ||
|
|
|
|
| ||
Orange & white Wires
Turning Off the Gas to the Appliance
1.Turn the remote switch to the OFF position.
2.Turn OFF all electrical power to the fireplace if service is required.
3.Open the lower access panel.
4.Turn the
1/2” Gas Supply
1/2” NPT x 3/8” Flare
3/8” Flex Line
(From Valve)
Valve in the “ON” position
26 | 10010618 |
