Gasoline Check

1.Remove the gasoline cap located on top of fuel tank.

2.Handle Fuel in a safety container. If the container does not have a spout use a funnel.

3.Visually inspect to see if fuel level is low. If fuel is low, replenish with unleaded fuel.When refueling, be sure to use a strainer for filtration. DO NOT top-off fuel. Wipe up any spilled fuel.

4.Payattentiontothefueltankcapacitywhenreplenishingfuel. Refer to the fuel tank capacity listed inTable 5.

WARNING - Explosive Fuel

Gasoline is extremely flammable, and its vapors can cause an explosion if ignited. DO NOT start the engine near spilled fuel or combustible fluids. DO NOT fill the fuel tank while the engine is running or hot.

DO NOT overfill tank, since spilled fuel could ignite if it comes into contact with hot engine parts or sparks from the ignition system. Store fuel in approved containers, in well-ventilated areas and away from sparks and flames. NEVER use fuel as a cleaning agent.

DO NOT smoke while refueling, motor fuels are highly flammable and can be dangerous if mishandled.

V-Belt Deflection

1.Visually inspect theV-belt for cracks, fraying, wear or oiliness.

2.Make sureV-belt does not the bottom the pulley groove.

3.ChecktheV-belttension(Figure19)bypushingmidwaythrough thetwopulleys.TheV-beltdeflectionshouldbebetween.300 to

.472 inches (8 to 12 mm).

INSPECTION

Lubrication Box

The C30HDZ model features a fully enclosed lubrication box, which utilizes the "splash" method of lubrication.

Before using your new pump, 7 gallons of SAE 30 motor oil must be added directly into the lubrication box.Visually inspect the oil in the lubrication box by making sure the oil is at the correct operating level as indicated by the dip stick (Figure 16).

Also reference the oil level decal (Figure 17) adjacent to the lubrication box.

Make sure the pump is on a secure

NOTE level surface when checking the oil level inside the lubrication box.

CAUTION - Checking Lubrication Oil Levels

The oil level must be checked daily to ensure adequate oil level and oil cleaniness.

Figure 19.V-Belt Deflection

Figure 16. Lubrication Box Dipstick

CAUTION

NORMAL

1”

LOW

Before starting engine, check that the oil level inside the “LUBE BOX” is within the indicated operating range. Recommended oil type SAE 30.

DCL 152

Figure 17. Lubrication Box Oil Caution Decal

MAYCO C30HDZ PUMP — OPERATION AND PARTS MANUAL — REV. #12 (04/03/12) — PAGE 35

Page 35
Image 35
Multiquip C30HDZ manual Gasoline Check, Belt Deflection, Inches 8 to 12 mm, Lubrication Box